TL* THE CONTACT OWNS A 2008 BMW R 1200 GS MOTORCYCLE. THE CONTACT STATED THAT THE MOTORCYCLE FUEL SENSOR STRIPS WERE REPLACED THREE TIMES, UNDER THE MANUFACTURER WARRANTY REPAIR. THE CONTACT HAD TAKEN THE MOTORCYCLE TO IRON HORSE MOTORCYCLES (344 E. GRANT RD, TUCSON, AZ, 85716, (520) 327-0773 AND THE THIRD FUEL SENSOR STRIP WAS REPLACED HOWEVER, THE REPAIR FAILED TO FIX THE FAILURE. THE CONTACT ST…
2008 BMW R 1200 GS fuel system problems
moderate 6 complaints filed with NHTSA · avg repair $1,200
Complaints
6
Recalls
0
Crashes
0
Avg fix
$1,200
What owners are reporting 6 most recent
The contact owns a 2008 BMW R 1200. The contact stated that while the motorcycle was parked, the contact smelled fuel on several occasions. No warning light was illuminated. The motorcycle had not been diagnosed or repaired. The manufacturer was made aware of the failure and determined that the VIN was not included in NHTSA Campaign number: 20V471000 (Fuel system, Gasoline). The failure mileage wa…
The contact owns a 2008 BMW R 1200 GS Motorcycle. The contact stated the vehicle was leaking fuel without warning. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified however, no further assistance was provided. The approximate failure mileage was 35,000.
TL* THE CONTACT OWNS A 2008 BMW R 1200 GS. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, WITHOUT WARNING AN ABNORMAL ODOR APPEARED AS FUEL POURED ONTO THE CONTACT. THE CONTACT COASTED THE MOTORCYCLE TO THE SHOULDER OF THE ROADWAY AND CONTACTED HIS FRIEND WHO HAULED THE MOTORCYCLE BACK TO THE CONTACT'S RESIDENCE. BIG #1 MOTORSPORTS (505 COBB STREET, 1-65 & OXMOOR RD BIRMINGHAM, AL 35209) WAS CON…
TL* THE CONTACT OWNS A 2008 BMW R1200 GS MOTORCYCLE. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT NOTICED THAT THE FINAL DRIVE UNIT AND DRIVE SHAFT WERE LEAKING A SMALL AMOUNT OF OIL. THE REAR WHEEL BEGAN TO WOBBLE EXCESSIVELY. THE VEHICLE WAS TOWED AN AUTHORIZED DEALER WHO REPLACED ONE WHEEL BEARING AND THE SEAL. THE FAILURE RECURRED AND THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WH…
A PLASTIC FLANGE ON THE FUEL PUMP CRACKED ALLOWING FUEL TO LEAK. THE FLANGE CONTAINS AN INTERNAL THREAD THAT SECURES ONE OF THE FUEL LINES. SEVERAL CRACKS ARE VISIBLE AROUND THE CIRCUMFERENCE OF THE FLANGE. CRACKS, IN MY OPINION, APPEAR TO BE RELATED TO OVER-TORQUE AT ASSEMBLY AND/OR MATERIAL DEGRADATION DUE TO THE COMBINED EFFECTS OF EXPOSURE TO FUEL, TIME AND AMBIENT TEMPERATURE. THE FUEL PUM…
Common questions
How serious is the fuel system problem on the 2008 BMW R 1200 GS?
It's a documented issue but not catastrophic. 6 complaints have been filed. Repairs average $1,200 and most owners catch it before it causes a breakdown.
At what mileage does the fuel system typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $1,200 for fuel system repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to fuel system?
No active recalls currently cover fuel system issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Severity ratings are derived from reported crashes, fires, injuries, and fatalities.
Repair cost estimates are independent-shop national averages and may differ in your area.
Some links on this page are affiliate links.