HOSE AND TUBE - EGR COOLANT
full bulletin at NHTSA ↗2020 Chrysler Voyager engine problems
moderate Owners of the 2020 Chrysler Voyager have filed 4 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
4
Recalls
0
Avg fix
$3,100
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0111-00 - Intake Air Temperature Sensor 1 Circuit Range Performance Bank 1. (In Active or Stored status) ● P0071-00 - Ambient Air Temperature Sensor Performance. (In Active or Stored status) ● P0072-00 - Ambient Air Temperature Sensor Circuit "A" Low. (In Active or Stored status) ● P0073-00 - Ambient Air Temperature Sensor Circuit "A" High. (In Active or Stored status) ● P0011-00 - Bank 1 Camshaft 1 Position Timing Over Advanced Or. (In Active or Stored status) ● P2
full bulletin at NHTSA ↗WATER PUMP
full bulletin at NHTSA ↗WATER PUMP
full bulletin at NHTSA ↗Water Pump & Chain Case Cover
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
Oil filter housing/ oil cooler catastrophic failure at 86519 miles pumping out oil and antifreeze and shutting vehicle down on i25 in Fort collins colorado creating hazard for us and other drivers. This is a known issue with this vehicle model and a recall has not been done from Chrysler. I repaired vehicle myself with an upgraded part from autozone.
All of a sudden the van starts running very hard, trying to stall, the stop/start warning comes on, engine light comes on and the van has a lot of trouble accelerating. If the van will stall in the middle of the road it would put me, my kids and other cars around me at risk, especially if we are on a fast highway. We took it to the dealer last year and they replaced all the coils and now the…
Coolant is leaking inside cylinder 3, head gasket is blown at 62000 miles.
Car completely stopped . After 2 months of checking the car I was told the motor is corroded. Bought the vehicle 2022 with no reports of any incidents
Had engine trouble with your 2020 Chrysler Voyager?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2020 Chrysler Voyager?
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2020/Chrysler/Voyager.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.