This bulletin provides information when there is increased oil consumption; >0.5ltr/1000 km.
full bulletin at NHTSA ↗2018 Audi S4 engine problems
moderate Owners of the 2018 Audi S4 have filed 3 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This bulletin provides informaiton when the engine is not running smoothly, misfiring.
full bulletin at NHTSA ↗This bulletin provides information when DTC U140A00 Terminal 30 is stored in the ECM.
full bulletin at NHTSA ↗This bulletin provides information when there is an abnormal engine knocking noise from the engine compartment; V6 3.0L TFSI.
full bulletin at NHTSA ↗This bulletin provides information when there is an abnormal engine knocking noise from the engine compartment; V6 3.0L TFSI.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
Water pump defect for the 3.0L ea839 turbo engine found across many Porsche and Audi models. Defect causes damage to vacuum lines, thermostat, and can eventually lead to engine failure if not resolved. No way of knowing this is happening until you start to lose coolant (which will throw an engine code), but by that point the damage is done. There was a recall for the previous generation vehicle…
PCV housing and lines failed. Caused pressure to build up thus shooting off the oil cap shooting oil everywhere! in addition to that it is a huge fire hazard considering the turbo is right next to it.
My 2018 Audi S4 has a catastrophic engine failure issue and this is common with the EA839 engine. There is a knocking in the motor that is caused by internal engine parts (rocker arms needle bearings) becoming loose and dislodged. The metal shavings travel in the motor oil and destroy the engine from the inside. Hendrick Audi northlake examined the car on February 26, and recommended a new engine…
Had engine trouble with your 2018 Audi S4?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2018 Audi S4?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2018/Audi/S4.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.