2010 Dodge Grand Caravan vs 2010 Mercury Milan
Reliability comparison based on NHTSA recall and complaint records.
2010 Dodge Grand Caravan
2010 Mercury Milan
Stories from the shop
Reliability scores run close (3.1 versus 3.3). The pick comes down to specific use case more than overall reliability scoring.
If you lean 2010 Dodge Grand Caravan, know what you're getting into on electrical and engine. Those categories have noticeably more complaints than the 2010 Mercury Milan sees, and they're not cheap items when they go.
Going with the 2010 Mercury Milan? Watch the steering and powertrain. The 2010 Dodge Grand Caravan has fewer reports in those categories, so you'd be trading one set of weak spots for another.
Bottom line: pick based on use case more than the spec sheet. If you tow heavy and don't want to think about it, that's one calculation. If you're a daily driver and want the cheapest path forward, that's another. Both of these will get you down the road. We're just telling you where each one is most likely to break.
Side-by-side by problem area
Common questions
Which is more reliable, the 2010 Dodge Grand Caravan or the 2010 Mercury Milan?
It's close to a tie. Both vehicles score within 0.2 points on our reliability index (3.1 vs 3.3). At this margin, either choice is defensible — base your decision on the specific failure modes that matter to you.
What goes wrong more often on the 2010 Dodge Grand Caravan?
Compared to the 2010 Mercury Milan, the 2010 Dodge Grand Caravan sees more reported issues in electrical and engine. That doesn't mean it's a bad truck — it means those are the categories worth budgeting for if you go that direction.
What goes wrong more often on the 2010 Mercury Milan?
Compared to the 2010 Dodge Grand Caravan, the 2010 Mercury Milan has more complaints in steering and powertrain. Whether that's a deal-breaker depends on the cost and severity — see the comparison table above for repair cost ranges.
Which has more recalls?
The 2010 Dodge Grand Caravan has more active recalls (2 vs 0). Total count is less important than severity, though — a vehicle with one critical recall and zero moderate ones is generally riskier than one with five moderate recalls.
Is an extended warranty worth it on either of these?
Both vehicles are out of factory bumper-to-bumper coverage at this point. Combined repair exposure across the top problem categories runs around $14,050 on the higher-risk vehicle. A quality service contract typically costs $1,800–3,500 over 3 years, so a single major failure usually pays for the contract. The math favors warranty coverage on whichever vehicle you choose, especially if you plan to keep it past 100,000 miles.