This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
full bulletin at NHTSA ↗2006 GMC Yukon engine problems
moderate 6 complaints filed with NHTSA · avg repair $3,100 · see engine across all vehicles →
Complaints
6
Recalls
0
Avg fix
$3,100
When does it fail?
Of the 6 engine complaints filed for the 2006 GMC Yukon, here's the actual mileage breakdown — failures cluster heaviest at 100,000-125,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA engine complaint has been filed on this vehicle in over 14 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
full bulletin at NHTSA ↗This bulletin advises the technician of possible location of an internal coolant leak from a specific cylinder head and location.
full bulletin at NHTSA ↗This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
full bulletin at NHTSA ↗This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
Recently, my check engine light came on in my 2006 yukon denali xl w/ a 6.0 engine. The diagnostic test showed a gas cap problem. However, this did not fix the issue. Several weeks later, the engine started making what sounded like a clicking sound. Upon further investigation, it was discovered that there was a leak in the driver's side exhaust manifold. While in the shop, the mechanic…
Exhaust leak. Bolt broken on driver side
Exhaust leak bolt broken passenger side
Had engine trouble with your 2006 GMC Yukon?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2006 GMC Yukon?
It's a documented issue but not catastrophic. 6 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 6 complaints filed, engine issues most often appear around 136,390 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/GMC/Yukon.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.