This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
full bulletin at NHTSA ↗2006 Hummer H2 electrical problems
severe 4 complaints filed with NHTSA · avg repair $850 · see electrical across all vehicles →
Complaints
4
Recalls
0
Avg fix
$850
1fire
When does it fail?
Of the 4 electrical complaints filed for the 2006 Hummer H2, here's the actual mileage breakdown — failures cluster heaviest at 150,000+ mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA electrical complaint has been filed on this vehicle in over 13 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering electrical on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
full bulletin at NHTSA ↗This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
full bulletin at NHTSA ↗The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
full bulletin at NHTSA ↗This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
At first the washers just kept spraying and wouldn't stop. I had to take out the fuse to get it to stop. I recently put the fuse back in and now it won't work. The washers will just start spraying out of the blue and this is very dangerous if you are driving down the road and you can't get it to stop. It decreases your visibility. I have read that they have had recalls on this issue. It sounds…
Vehicle had been driven approximately 2 miles from start time, was stationary and unoccupied for approximately 10-25 minutes. Vehicle interior caught fire at the base of the top sitting area of the rear seat, flames from fire melted the over head interior light and ignited a fire on the head liner, which caused the fire to spread under neath the headliner and roof of the vehicle, melting the…
The contact owns a 2006 Hummer H2. The contact stated while driving and activating the blower motor, the blower motor was intermittently inoperable. The contact stated that an abnormal electrical burning odor was coming from the vehicle. The contact stated that upon activation, the A/C and the heating systems were intermittently inoperable. The vehicle was taken to an independent mechanic, where…
The contact owns a 2006 Hummer H2. The contact stated while driving at undisclosed speeds with the A/C activated, the contact became aware of an abnormal burning electrical odor. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the blower motor resistor needed to be replaced. The vehicle was not repaired. The…
Had electrical trouble with your 2006 Hummer H2?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the electrical problem on the 2006 Hummer H2?
It's a meaningful issue. 4 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $850.
At what mileage does the electrical typically fail?
Based on the 4 complaints filed, electrical issues most often appear around 168,667 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $850 for electrical repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to electrical?
No active recalls currently cover electrical issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Hummer/H2.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.