GM: IF THE SERVICE SUSPENSION SYSTEM IS DISPLAYED ON THE DIC, THE TRIM HEIGHT MAY BE INCORRECT, LOOSE COMPRESSOR INLET HOSE, OR THE COMPRESSOR SELF TEST MAY BE INOPERATIVE. ALSO INCLUDED SUBURBAN LD MY 2001-2013, YUKON DENALI XL MY 2013, YUKON XL LD 2001-2013
full bulletin at NHTSA ↗2006 Chevrolet Avalanche suspension problems
moderate Owners of the 2006 Chevrolet Avalanche have filed 3 NHTSA complaints about the suspension at roughly $900 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See suspension across all vehicles →
Complaints
3
Recalls
0
Avg fix
$900
| Model year | suspension complaints |
|---|---|
| 2006 Avalanche (this page) | 3 |
| 2007 Avalanche | 5 |
| 2008 Avalanche | 3 |
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering suspension on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This Preliminary Information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. Technician should not replace the bearing for grease purge. Technician should be advised to not clean the purged grease from the area immediately on or adjacent to the seals because this grease provides additional protection. Technician should only replace the bearing if the seals show visible damage, bearing endplay is greater than 0.005" or 0.13mm, bearing exhibits rough rotation, or bearing exhibits abnormal noise.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 0 most recent
Had suspension trouble with your 2006 Chevrolet Avalanche?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the suspension problem on the 2006 Chevrolet Avalanche?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $900 and most owners catch it before it causes a breakdown.
At what mileage does the suspension typically fail?
Based on the 3 complaints filed, suspension issues most often appear around 26,475 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $900 for suspension repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to suspension?
No active recalls currently cover suspension issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Chevrolet/Avalanche.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.