HYUNDAI: POWER STEERING GEAR BOX YOKE KIT INSTALLATION PROCEDURE. IF VEHICLE EXHIBITS A SLIGHT RATTLE NOISE ORIGINATING FROM THE STEERING GEAR BOX WHEN TURNING RIGHT ON UNEVEN ROAD SURFACES, REPLACE THE SUPPORT YOKE AND YOKE SPRING WITH THE SUPPORT YOKE KIT USING THE PROCEDURE DESCRIBED IN THIS BULLETIN. NOTE: NO STEERING PERFORMANCE ISSUES ASSOCIATED WITH THIS CONDITION.
full bulletin at NHTSA ↗2006 Hyundai Santa Fe steering problems
moderate 4 complaints filed with NHTSA · avg repair $700 · see steering across all vehicles →
Complaints
4
Recalls
0
Avg fix
$700
When does it fail?
Of the 4 steering complaints filed for the 2006 Hyundai Santa Fe, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA steering complaint has been filed on this vehicle in over 11 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering steering on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 2 most recent
Tl* the contact owns a 2006 Hyundai santa fe. While driving various speeds and making a right turn, a squealing noise emitted from underneath the vehicle. Also, the vehicle lunged forward when making a turn. The vehicle was taken to an independent mechanic. The technician discovered that the steering shaft was bent and needed to be replaced. The vehicle was repaired, but the squealing sound…
Tl* the contact owns a 2006 Hyundai santa fe. The contact stated that the vehicle was exhibiting a winding sound when turning in any direction. The vehicle was taken to the dealer where both the power steering pump and the rack and pinion were replaced. The contact had to take the vehicle back three times after the repair due to the recurrence of the failure. The dealer replaced the power…
Had steering trouble with your 2006 Hyundai Santa Fe?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the steering problem on the 2006 Hyundai Santa Fe?
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $700 and most owners catch it before it causes a breakdown.
At what mileage does the steering typically fail?
Based on the 4 complaints filed, steering issues most often appear around 41,357 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $700 for steering repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to steering?
No active recalls currently cover steering issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Hyundai/Santa Fe.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.