This is a service newsletter (Tech Talk) that was sent out to dealers.
full bulletin at NHTSA ↗2006 Mitsubishi Galant brakes problems
moderate 3 complaints filed with NHTSA · avg repair $450 · see brakes across all vehicles →
Complaints
3
Recalls
0
Avg fix
$450
When does it fail?
Of the 3 brakes complaints filed for the 2006 Mitsubishi Galant, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA brakes complaint has been filed on this vehicle in over 18 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This is a service newsletter (Tech Talk) that was sent out to dealers.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
At about 6000 miles my brakes began to squeak. The dealer replaced the rear pads. The brakes still squeaked. The dealer replaced the front pads, saying they had found a "service bulletin" which addressed the problem. For a short time the brakes were ok, but now (at 11000 miles) are squeaking again. I am trying to determine if there are others with the same problem or if there is in fact a…
Lamp sockets for both left and right side brake lights burnt out at 5 years, 2 months with less than 50,000 miles. If one side went out I'd call it a manufacturer defect. Both sides,...seems more like an engineering problem. Only the contact for the brake side of the 2057 lamp was melted and recessed. The tail lamp side of the socket is still clean. Put in a gm replacement socket which looks…
Problems with the brakes on 2006 Mitsubishi galant. The brakes were squeaking so I took it into the shop. They said they replaced the brakes pads this was at 16945 miles, again at 22380 miles, replace back brakes at 23403 now the brakes are gone again at 28552. They told me that it was just brake dust and no problem with the brakes but in less then 3 weeks the brakes are down metal to metal.…
Had brakes trouble with your 2006 Mitsubishi Galant?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2006 Mitsubishi Galant?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $450 and most owners catch it before it causes a breakdown.
At what mileage does the brakes typically fail?
Based on the 3 complaints filed, brakes issues most often appear around 30,973 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Mitsubishi/Galant.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.