SLIP LIGHT ON AFTER REPLACEMENT OF ESP ACTUATOR ASSEMBLY, SERVICE MANUAL UPDATE.
full bulletin at NHTSA ↗2006 Suzuki Grand Vitara brakes problems
moderate Owners of the 2006 Suzuki Grand Vitara have filed 8 NHTSA complaints about the brakes, typically surfacing around 44,905 miles at roughly $450 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
Failure mileage
Complaints
8
Recalls
0
Avg fix
$450
When does it fail?
Of the 8 brakes complaints filed for the 2006 Suzuki Grand Vitara, here's the actual mileage breakdown — failures cluster heaviest at 50,000-75,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA brakes complaint has been filed on this vehicle in over 14 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 1 most recent
Tl* the contact owns a 2006 Suzuki grand vitara. The contact stated that while driving 20 MPH, the esp control module illuminated and the ABS braking control engaged after the brakes were depressed. The vehicle was taken to an authorized dealer and the dealer stated that the esp control module needed to be replaced. The manufacturer was notified. The vehicle was not repaired. The failure mileage…
Had brakes trouble with your 2006 Suzuki Grand Vitara?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2006 Suzuki Grand Vitara?
It's a documented issue but not catastrophic. 8 complaints have been filed. Repairs average $450 and most owners catch it before it causes a breakdown.
At what mileage does the brakes typically fail?
Across the 8 complaints that reported odometer mileage, most brakes failures cluster between 12,000 and 85,000 miles, with the median around 44,905. A quarter of owners report trouble before 12,000; a quarter make it past 85,000. Maintenance history matters more than the odometer alone — this is the reported failure window, not a guarantee.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Suzuki/Grand Vitara.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.