THIS SERVICE BULLETIN UPDATES A BULLETIN ORIGINALLY ISSUED ON MAY 18, 2016, CONCERNING A SPECIAL WARRANTY EXTENSION (ZH) FOR 2005-2008 SUZUKI FORENZA AND SUZUKI RENO VEHICLES. THE UPDATES ARE: (1) THE EXISTENCE OF DIAGNOSTIC TROUBLE CODE (DTC) B1379 IS ADDED TO THE LIST OF DTCS THAT MAKE A VEHICLE ELIGIBLE FOR REPAIR UNDER SPECIAL WARRANTY EXTENSION ZH; AND (2) THE PROCEDURE FOR INSPECTING THE SEAT HEIGHT ADJUSTER FOR DAMAGE HAS BEEN CLARIFIED.
full bulletin at NHTSA ↗2006 Suzuki Reno airbags problems
severe Owners of the 2006 Suzuki Reno have filed 10 NHTSA complaints about the airbags at roughly $1,100 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See airbags across all vehicles →
Complaints
10
Recalls
0
Avg fix
$1,100
| Model year | airbags complaints |
|---|---|
| 2005 Reno | 17 |
| 2006 Reno (this page) | 10 |
| 2007 Reno | 10 |
| 2008 Reno | 3 |
1crash
1injury
When does it fail?
Of the 10 airbags complaints filed for the 2006 Suzuki Reno, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA airbags complaint has been filed on this vehicle in over 11 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering airbags on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
AIRBAG LIGHT ON; DTC B1378 (DRIVER SIDE AIRBAG RESISTANCE TOO HIGH) AND/OR DTC B1382 (PASSENGER SIDE AIRBAG RESISTANCE TOO HIGH). FORENZA, SEDAN/WAGON, RENO (RQ420) 2005-2006. VIN(S) -6K425022.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
The failure pattern owners describe
Owners of the 2006 Suzuki Reno consistently report airbag warning lights that either stay on continuously or return within days after dealer service. One owner's light has been on for years since 2007 despite multiple dealer visits, connector tightening, and sensor work. Dealers have cleared codes like B1102 (low battery voltage) and B1378/B1382 (resistance errors on driver and passenger sides), cleaned connectors, replaced sensors, and even replaced a passenger seat cushion assembly—none of it solved the problem permanently.
Two owners describe their airbags failing to deploy during actual accidents. One was rear-ended at 65 mph, swerved into oncoming traffic, and hit by a semi; the airbags didn't deploy and his son was injured. Another owner reports airbags failed to deploy in a crash after the warning lights had been coming on for months.
Passenger side sensors are particularly problematic—lights trigger when passengers sit down, move, or the car hits a bump, suggesting the occupancy detection isn't working reliably. One owner reports a dealer replaced the passenger sensor but the light never turned off, raising the question whether the airbag would actually fire in a crash.
An owner cites a Technical Service Bulletin (TS0501158) related to overpressure airbags but notes no recall has been issued. Repair costs range from $105 for connector work to $700 estimates for full fixes, and the work often fails to last.
Same Suzuki Reno airbags reports on nearby years: 2005 · 2007
Failure modes owners describe
Airbag warning light stays on or returns repeatedly
The airbag warning light illuminates and does not turn off or returns within days to weeks after dealer service. Multiple owners report the light staying on continuously for years despite repeated dealer visits, connector cleaning, and sensor replacement attempts. The issue appears unresponsive to temporary fixes and persists or recurs out of warranty.
When: Varies from 6 miles to 121,437 miles; reported as early as 2007 and continuing through 2014 on vehicles purchased new in 2006
Symptoms owners cite: Airbag warning light continuously illuminated or intermittently on; Light turns off briefly after dealer service then returns; Light triggered by passenger movement or road bumps; Both driver and passenger side lights affected
Codes mentioned: B1102 Low Battery Voltage, B1378 Driver's Side Resistance Too High, B1382 Right Side Resistance
Repairs/costs cited: Dealer cleaned and tightened connectors under seats; replaced passenger front seat cushion assembly; replaced sensors; one owner cited $700 estimate for repair; one dealer charged $105 for connector stabilizer work
Recalls/TSBs owners mention: Technical Service Bulletin TS0501158 exists related to overpressure airbag; no official recall issued per owner reports
Airbag non-deployment in accident
In at least two documented accidents, airbags failed to deploy despite impact severity warranting deployment. One rear-end collision with secondary semi-truck impact at 65 mph resulted in passenger injury; another accident with no airbag deployment reported. In both cases, warning lights were either illuminated beforehand or failed to warn.
When: Accidents occurred; one at 50,000 miles
Symptoms owners cite: Airbags did not deploy in rear-end collision; Airbags did not deploy in secondary accident impact; No warning indicators illuminated in one incident despite collision; Passenger sustained neck, back, and shoulder injuries when airbags failed to deploy
Repairs/costs cited: No repairs completed; police report filed in one incident
Passenger airbag sensor malfunction
Passenger side airbag warning light does not extinguish when a passenger is seated, or illuminates intermittently despite passenger presence. One owner reports light would not go off when passenger seat occupied even after sensor replacement, indicating the airbag would not activate in a crash.
When: Reported at various mileages from early in ownership
Symptoms owners cite: Passenger airbag light remains on when passenger seated; Light triggers when passenger moves; Light triggers when vehicle hits road bump; Airbag will not activate per owner assessment
Repairs/costs cited: Dealer replaced sensor under seat; did not resolve light or sensor function
Synthesized from 10 NHTSA owner complaints — unverified consumer allegations, summarized for patterns. The verbatim filings appear below.
What owners are reporting 1 most recent
Air bag light has been on almost continuously since october 2007 (vehicle purchased new in june 2006). Dealer in nevada checked vehicle october 2007 (mileage 20,788), found codes b1102 low battery voltage and b1378 drivers side resistance too high. Cleared codes, tightened connector under passenger seat (no cost); light was off for about a week then back on. Dealer advised I should just snug up…
Had airbags trouble with your 2006 Suzuki Reno?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the airbags problem on the 2006 Suzuki Reno?
It's a meaningful issue. 10 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $1,100.
At what mileage does the airbags typically fail?
Based on the 10 complaints filed, airbags issues most often appear around 49,744 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,100 for airbags repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to airbags?
No active recalls currently cover airbags issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Suzuki/Reno.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.