This technical bulletin provides information and a solution to a condition of Brake Pedal Moves or Self Applies at Full Turns.
full bulletin at NHTSA ↗2007 GMC Savana brakes problems
severe Owners of the 2007 GMC Savana have filed 4 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
Complaints
4
Recalls
0
Avg fix
$450
| Model year | brakes complaints |
|---|---|
| 2005 Savana | 6 |
| 2007 Savana (this page) | 4 |
1crash
1injury
When does it fail?
Of the 4 brakes complaints filed for the 2007 GMC Savana, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA brakes complaint has been filed on this vehicle in over 8 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
full bulletin at NHTSA ↗This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.
full bulletin at NHTSA ↗This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
full bulletin at NHTSA ↗This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
Tl* the contact owned a 2007 GMC savana. While driving approximately 20 MPH, the driver attempted to stop, but the brakes failed. As a result, the contact crashed into the preceding vehicle. There were no warning indicators illuminated. The air bags did not deploy. The driver sustained injuries that required medical attention. A police report was filed. The vehicle was totaled and was towed to a…
Tl* the contact owns a 2007 GMC savana. The contact stated that the ABS system failed. The vehicle was taken to the dealer where the technician diagnosed that a sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 92,414.
Intermittent brake lock up on 2007 GMC savana 2500 cargo van. The pedal feels hard to push and the vehicle will not slow. More pressure applied to the brake pedal then the front brakes lock up completely. This happened twice at low speeds and once at freeway speed. Very fortunate that other drivers were able to avoid a truck skidding to a stop on the freeway. Turning the vehicle off for five…
Tl* the contact owns a 2007 GMC savanna. The contact stated that the vehicle failed to respond to deceleration attempts. The vehicle was taken to the dealer who stated that the brake booster and brake booster lines were defective and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the defect. The failure mileage was 36,000.
Had brakes trouble with your 2007 GMC Savana?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2007 GMC Savana?
It's a meaningful issue. 4 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $450.
At what mileage does the brakes typically fail?
Based on the 4 complaints filed, brakes issues most often appear around 69,354 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2007/GMC/Savana.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.