Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2007 Suzuki XL7 fuel system problems
moderate
Owners of the 2007 Suzuki XL7 have filed 8 NHTSA complaints about the fuel system at roughly $1,200 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation.See fuel system across all vehicles →
Complaints
8
Recalls
1
Avg fix
$1,200
What stands out
No new NHTSA fuel system complaint has been filed on this vehicle in over 12 years — the issue may be aging out of the active population.
American Suzuki is recalling certain model year 2007 XL-7 vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; and manufactured June 13, 2006, through December 22, 2006
Fuel leakage in the presence of an ignition source may result in a fire.
Fix: American Suzuki will notify owners, and dealers will replace the fuel pump module, free of charge. An interim letter was mailed on March 7, 2013. Owners may contact American Suzuki Customer Relations at 1-800-934-0934.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering fuel system on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service BulletinTSB-TS-27-07313Jan 2014
SUZUKI: WHEN VEHICLE IS EITHER PARKED OR BEEN DRIVEN, CAN SMELL AN ODOR OF FUEL, OR CAN OBSERVED FUEL DRIPPING, AROUND AREA OF FUEL TANK IN REAR OF VEHICLE, DUE TO CRACK IN PLASTIC SUPPLY OR RETURN PORT OF FUEL PUMP MODULE, CAUSING THE ODOR. MODEL 2007-2009 XL7.
SUZUKI: WHERE PLASTIC SUPPLY OR RETURN PORT ON FUEL PUMP MODULE, THERE IS A CRACK THAT CAN CAUSE A FUEL LEAK AND WHILE BEING DRIVEN OR PARKING, FUEL ODOR MAY BE NOTICED AND COULD BECOME LARGER AND DRIP ON THE GROUND. MODEL 2007-2009 XL7.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
1 most recent
fuel system
· filed 11/13/2013
2007 Suzuki xl7. Consumer writes in regards to a defective fuel pump module. *smd the consumer stated he/she didn't receive a recall notice, until five years later, following Suzuki's testing that a defect existed. The consumer would like to have the matter investigated and impose fines against general motors, Suzuki and bosch, due to their intentional concealment and untimely delay at…
Had fuel system trouble with your 2007 Suzuki XL7?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the fuel system problem on the 2007 Suzuki XL7?
It's a documented issue but not catastrophic. 8 complaints have been filed. Repairs average $1,200 and most owners catch it before it causes a breakdown.
At what mileage does the fuel system typically fail?
Based on the 8 complaints filed, fuel system issues most often appear around 156,667 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,200 for fuel system repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to fuel system?
Yes — 1 active recall(s) cover fuel system issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2007/Suzuki/XL7.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.