Check any vehicle by VIN

Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.

Couldn't find that VIN. Check the digits and try again.

ProblemsByVin Checklist / 2009-FORD-F-250

Pre-purchase · Buyer's checklist

2009 Ford F-250 inspection checklist

The 2009 Ford F-250 has 77 owner complaints with NHTSA across 5 component categories. Use this checklist before you put money down — every item below is grounded in the actual failure pattern on this vehicle, not generic advice.

1 Inspect the steering

What to look for: Wandering on the highway, clunks when turning, slop in the wheel before the tires respond, power steering whine. (39 owner complaints on this vehicle · typical repair $700 · failures cluster ~82,936 mi)

Tire wear pattern — uneven wear across the tread means alignment or worn suspension
Power steering fluid level (where applicable — most newer vehicles are electric)
Tie rod boots and ball joint boots for tears
Steering wheel free play — should be less than 1 inch at the rim

On the test drive: On a smooth highway, take hands off briefly (when safe) — vehicle should track straight. Pulling left or right means alignment or worn front-end parts.

See full steering report for this vehicle →

2 Inspect the engine

What to look for: Blue smoke on cold start (oil burning), white smoke at temperature (coolant), knock or tick that doesn't go away after warm-up, oil spots under the vehicle. (9 owner complaints on this vehicle · typical repair $3,100 · failures cluster ~44,193 mi)

Oil dipstick — level on the full mark, color amber not black, no milky residue (head gasket sign)
Coolant reservoir — level, no oil film floating, no rust
Spark plug wells (look down with a flashlight) — oil pooled means valve cover gasket
Timing chain or belt service history (interference engines = $1,500+ if it breaks)
Exhaust smoke briefly after a long idle then a rev

On the test drive: Drive until the gauge reaches operating temp, then check temp stability under load on a hill. Surging or temp climbing under load = thermostat or water pump.

See full engine report for this vehicle →

3 Inspect the suspension

What to look for: Bouncing after bumps, knocking over potholes, sagging on one corner, harsh ride with all the dampening gone. (8 owner complaints on this vehicle · typical repair $900 · failures cluster ~138,379 mi)

Bounce test — push down hard on each corner of the car; it should rebound once and settle, not bounce
Visible struts/shocks behind the wheels for oil leaks
Sway bar end links and bushings (common wear item, $40–$120 to fix)
Ride height — measure wheel-well to ground at all four corners; uneven = bad spring

On the test drive: Drive over a series of bumps or a railroad crossing — clunks point to worn end links, ball joints, or strut mounts.

See full suspension report for this vehicle →

4 Inspect the tires

What to look for: Uneven tread wear (alignment or suspension), feathering (toe out of spec), cupping (worn shocks), sidewall cracks (age). (6 owner complaints on this vehicle · typical repair $150 · failures cluster ~7,024 mi)

Tread depth at multiple points across each tire — should be even across the width
DOT date code on the sidewall — last 4 digits are week and year; 6+ years old = replace regardless of tread
Sidewall for cracks, bubbles, or repair patches
Spare tire — present, inflated, and the jack/wrench are in the kit

See full tires report for this vehicle →

5 Inspect the fuel system

What to look for: Anything that looks, sounds, or smells different from peer vehicles of the same year and trim. (3 owner complaints on this vehicle · typical repair $1,200 · failures cluster ~59,219 mi)

Walk around and note any visible damage, wear, or aftermarket modifications
Open the hood and look for fresh fluid leaks, loose connectors, or recent part swaps
Sit in every seat and operate every control to confirm function

See full fuel system report for this vehicle →

6 Paperwork — before you sign

The seller's transparency on these tells you what kind of seller you're dealing with.

Title in seller's name (not "open title" or "signed by previous owner")
Service records — at least the last 24 months
VIN on the dash matches the door jamb sticker and the title
Run a paid vehicle history report (Carfax or AutoCheck) — accident, salvage, odometer rollback
Confirm any open recalls have been completed (NHTSA VIN lookup)
If financing, get the rate in writing before you set foot on the lot

Inspection items derived from 77 owner complaints and 1 active recall campaigns filed with NHTSA on the 2009 Ford F-250. Category-specific guidance is written by ProblemsByVin contributors with ASE-certified mechanic review. This checklist is meant to surface known patterns — it doesn't replace a paid pre-purchase inspection by a qualified shop, which we recommend for any used vehicle priced over a few thousand dollars.

Get a free warranty quote →

Sponsored — we earn a commission if you complete a quote. Disclosure.