Check any vehicle by VIN

Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.

Couldn't find that VIN. Check the digits and try again.

ProblemsByVin Checklist / 2010-FORD-EXPEDITION

Pre-purchase · Buyer's checklist

2010 Ford Expedition inspection checklist

The 2010 Ford Expedition has 58 owner complaints with NHTSA across 6 component categories. Use this checklist before you put money down — every item below is grounded in the actual failure pattern on this vehicle, not generic advice.

1 Inspect the powertrain

What to look for: Hesitation on takeoff, harsh or delayed shifts, vibration at highway speed, fluid leaks on the driveway under the engine bay or transmission pan. (10 owner complaints on this vehicle · typical repair $2,500 · failures cluster ~58,632 mi)

Transmission fluid color and smell — fresh ATF is red, brown or burnt smell is bad
Engine and transmission mounts (cracks or visible sag)
CV boots front (and rear on AWD) — any tears mean a $300–$800 axle replacement
Driveshaft U-joints and rear differential fluid level on RWD/AWD

On the test drive: Drive 15+ minutes including a freeway on-ramp at full throttle, a steep hill, and stop-and-go traffic. Listen for clunks on shifts, flares between gears, and shudders during light acceleration at 30–50 mph (torque converter symptom).

See full powertrain report for this vehicle →

2 Inspect the body

What to look for: Paint mismatch between panels (prior accident), rust on rocker panels and wheel wells, door alignment gaps that don't match side-to-side, weatherstrip wear. (8 owner complaints on this vehicle · typical repair $1,500 · failures cluster ~52,535 mi)

Panel gaps — should be even and consistent; tight on one side means body work
Trunk and hood weatherstrips for cracks
Inside the trunk, under the spare — water staining means a leak
Door hinge bolts for paint dust (telltale of door replacement)
VIN plate on the dash matches the VIN sticker on the door jamb

See full body report for this vehicle →

3 Inspect the electrical

What to look for: Dim or flickering dash lights at idle, slow window operation, intermittent infotainment glitches, parasitic battery drain (dead battery after a few days parked). (7 owner complaints on this vehicle · typical repair $850 · failures cluster ~86,875 mi)

Battery age sticker — most batteries last 3–5 years
Alternator output at idle (13.8–14.5V is healthy)
All exterior lights: headlights both beams, taillights, brake lights, reverse, blinkers
Every interior switch: power windows, locks, mirrors, sunroof, seats
Infotainment cold-start time and touchscreen responsiveness

On the test drive: Cycle through every electronic accessory during the drive — heated seats, defrosters, climate fan on max, cruise control. Glitches show up under load.

See full electrical report for this vehicle →

4 Inspect the engine

What to look for: Blue smoke on cold start (oil burning), white smoke at temperature (coolant), knock or tick that doesn't go away after warm-up, oil spots under the vehicle. (5 owner complaints on this vehicle · typical repair $3,100 · failures cluster ~60,733 mi)

Oil dipstick — level on the full mark, color amber not black, no milky residue (head gasket sign)
Coolant reservoir — level, no oil film floating, no rust
Spark plug wells (look down with a flashlight) — oil pooled means valve cover gasket
Timing chain or belt service history (interference engines = $1,500+ if it breaks)
Exhaust smoke briefly after a long idle then a rev

On the test drive: Drive until the gauge reaches operating temp, then check temp stability under load on a hill. Surging or temp climbing under load = thermostat or water pump.

See full engine report for this vehicle →

5 Inspect the airbags

What to look for: Anything that looks, sounds, or smells different from peer vehicles of the same year and trim. (3 owner complaints on this vehicle · typical repair $1,100 · failures cluster ~118,998 mi)

Walk around and note any visible damage, wear, or aftermarket modifications
Open the hood and look for fresh fluid leaks, loose connectors, or recent part swaps
Sit in every seat and operate every control to confirm function

See full airbags report for this vehicle →

6 Inspect the visibility

What to look for: Wiper streaks even on a fresh blade, blower fan that doesn't change speeds, foggy or yellowed headlight lenses, sunroof drains plugged (water on headliner). (3 owner complaints on this vehicle · typical repair $350 · failures cluster ~26,133 mi)

All wiper speeds front and rear (if equipped) plus washer fluid spray pattern
Defroster — front and rear, every grid line working on the rear glass
HVAC fan on every setting, plus mode (vent, floor, defrost) selector
Sunroof open/close and tilt — check for grinding noises

See full visibility report for this vehicle →

7 Paperwork — before you sign

The seller's transparency on these tells you what kind of seller you're dealing with.

Title in seller's name (not "open title" or "signed by previous owner")
Service records — at least the last 24 months
VIN on the dash matches the door jamb sticker and the title
Run a paid vehicle history report (Carfax or AutoCheck) — accident, salvage, odometer rollback
Confirm any open recalls have been completed (NHTSA VIN lookup)
If financing, get the rate in writing before you set foot on the lot

Inspection items derived from 58 owner complaints and 0 active recall campaigns filed with NHTSA on the 2010 Ford Expedition. Category-specific guidance is written by ProblemsByVin contributors with ASE-certified mechanic review. This checklist is meant to surface known patterns — it doesn't replace a paid pre-purchase inspection by a qualified shop, which we recommend for any used vehicle priced over a few thousand dollars.

Get a free warranty quote →

Sponsored — we earn a commission if you complete a quote. Disclosure.