Certain 2016-2017 Model Year Focus RS Vehicles - Cylinder Head Gasket Replacement
full bulletin at NHTSA ↗2011 Ford Focus engine problems
moderate Owners of the 2011 Ford Focus have filed 3 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2007 Focus | 11 |
| 2008 Focus | 9 |
| 2009 Focus | 9 |
| 2010 Focus | 27 |
| 2011 Focus (this page) | 3 |
| 2012 Focus | 177 |
| 2013 Focus | 102 |
| 2014 Focus | 147 |
| 2015 Focus | 75 |
When does it fail?
Of the 3 engine complaints filed for the 2011 Ford Focus, here's the actual mileage breakdown — failures cluster heaviest at 125,000-150,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Of the 14 model years of Ford Focus we track for engine problems, this one has the fewest owner complaints on file (3).
No new NHTSA engine complaint has been filed on this vehicle in over 7 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
full bulletin at NHTSA ↗FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION.
full bulletin at NHTSA ↗FORD: THE IDLE SPEED DROPS LOWER THAN DESIRED AND MAY FLUCTUATE. THERE MAY BE TWO POSSIBLE TROUBLE CODES STORED.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 1 most recent
Tl* the contact owns a 2011 Ford focus. While driving 35 MPH, the vehicle stalled. When the contact attempted to restart the vehicle, all the warning indicators illuminated and remained lit, but the vehicle did not start. The vehicle was taken to nick abraham elyria Ford (1115 e broad st, elyria, oh 44035, 440-366-3673) to be diagnosed, but the failure could not be duplicated. The dealer was able…
Had engine trouble with your 2011 Ford Focus?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2011 Ford Focus?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 3 complaints filed, engine issues most often appear around 81,556 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2011/Ford/Focus.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.