Lubricating engine components before reassembly.
full bulletin at NHTSA ↗2011 Volkswagen Touareg engine problems
moderate 3 complaints filed with NHTSA · avg repair $3,100 · see engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
When does it fail?
Of the 3 engine complaints filed for the 2011 Volkswagen Touareg, here's the actual mileage breakdown — failures cluster heaviest at 50,000-75,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA engine complaint has been filed on this vehicle in over 4 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Instruction, how to lubicate engine before initial start.
full bulletin at NHTSA ↗Volkswagen Engine Oil Standards
full bulletin at NHTSA ↗This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the error message ERP0204E could occur during perform initial operation, software configuration, SVM updates for any control module(s) etc.
full bulletin at NHTSA ↗Engine misfire diagnostic aid.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
On my 2011 VW Touareg TDI there is an exhaust leak. Can be smelled within seconds of starting it. A turbo/EGR pipe cracks and the result is a serious exhaust leak under hood right next to where air is drawn into the cabin for HVAC. Parts are backordered with no ETA. Even though when driving there is exhaust getting into the car the dealer and VW corporate just says "sorry for the delay of the…
Tl* the contact owns a 2011 Volkswagen touareg. The contact stated while driving 45 MPH, the check engine warning light was illuminated. The vehicle was taken to Volkswagen of norwood (1280 providence hwy, norwood, ma 02062) where it was diagnosed with the catalytic converter needing to be replaced. The vehicle had been repaired under an unknown recall however, the failure occurred. The…
Water found in the air intake box during air filter change on my 2011 vw touareg. Bottom 3.5 inches of old filter was found wet when air box was opened. This is a serious issue as liquid water that enters the engine during operation can cause the engine to stall while in traffic resulting in a serious safety issue. Water or filter material ingestion into the engine can also result in…
Had engine trouble with your 2011 Volkswagen Touareg?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2011 Volkswagen Touareg?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 3 complaints filed, engine issues most often appear around 78,016 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2011/Volkswagen/Touareg.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.