This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the âTire Balance Data Sheetâ must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
full bulletin at NHTSA ↗2012 Hyundai Santa Fe wheels problems
moderate Owners of the 2012 Hyundai Santa Fe have filed 3 NHTSA complaints about the wheels at roughly $400 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See wheels across all vehicles →
Complaints
3
Recalls
0
Avg fix
$400
| Model year | wheels complaints |
|---|---|
| 2012 Santa Fe (this page) | 3 |
| 2013 Santa Fe | 6 |
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering wheels on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
full bulletin at NHTSA ↗This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). The rear wheel speed sensor is available as a separate service part from the rear wheel hub assembly. When appropriate, it is recommended to replace only the rear wheel speed sensor instead of the full assembly.
full bulletin at NHTSA ↗If the rear wheel hub in the affected vehicles is submerged in salt water, salt water can enter the rear wheel speed sensor housing and may interrupt the rear wheel speed sensor signal and temporarily illuminate the ABS and/or ESC warning lights in the instrument cluster until the sensor dries. For these cases, replacement of the wheel speed sensor cap is required. If no ABS/ESC warning lamp is illuminated, applying a silicone spray to the sensor is required. This bulletin describes the service procedure for the rear wheel speed sensors.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 0 most recent
Had wheels trouble with your 2012 Hyundai Santa Fe?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the wheels problem on the 2012 Hyundai Santa Fe?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $400 and most owners catch it before it causes a breakdown.
At what mileage does the wheels typically fail?
Based on the 3 complaints filed, wheels issues most often appear around 103,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $400 for wheels repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to wheels?
No active recalls currently cover wheels issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2012/Hyundai/Santa Fe.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.