Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
full bulletin at NHTSA ↗2014 Lincoln Navigator powertrain problems
moderate Owners of the 2014 Lincoln Navigator have filed 7 NHTSA complaints about the powertrain at roughly $2,500 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See powertrain across all vehicles →
Complaints
7
Recalls
0
Avg fix
$2,500
| Model year | powertrain complaints |
|---|---|
| 2012 Navigator | 5 |
| 2013 Navigator | 6 |
| 2014 Navigator (this page) | 7 |
| 2015 Navigator | 5 |
| 2018 Navigator | 16 |
When does it fail?
Of the 7 powertrain complaints filed for the 2014 Lincoln Navigator, here's the actual mileage breakdown — failures cluster heaviest at 75,000-100,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA powertrain complaint has been filed on this vehicle in over 5 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering powertrain on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Some 2013-2018 F-150/Expedition/Navigator vehicles equipped with four wheel drive (4WD) may exhibit an intermittent grinding noise while driving in two wheel drive (2WD) mode most commonly on acceleration. This may be due to a loss of vacuum to the integrated wheel end (IWE) actuators and/or wear of the IWE components. To correct the condition, follow the Service Procedure steps to replace the worn vacuum and/or IWE components.
full bulletin at NHTSA ↗On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 7 most recent
Tl* the contact owns a 2014 Lincoln navigator. The contact stated that while at a stop and to go, the vehicle loss motive power between first and second gear, failing to accelerate as designed. There was no warning light illuminated. The vehicle was take roberts motors inc., (4350 n alby st, alton, il 62002) where the transmission fluid was change and a new hose was replaced however, the repairs…
Tl* the contact owns a 2014 Lincoln navigator. While driving various speeds, the vehicle downshifted intermittently without warning into first gear. The contact had to turn the vehicle off and back on for the vehicle to resume normal operation. The vehicle was taken to john wiese Ford (203 10th st s, sauk centre, mn 56378, (888) 868-6561) where it was diagnosed that the lead frame was faulty and…
My vehicle exhibits an illuminated malfunction indicator light (MIL) and sometimes a wrench light in the instrument cluster. I had a diagnostic done on my truck to troubleshoot issue and the code was P0720. Ford issued a recall on Lincoln Navigator built between April 11, 2011 through August 19, 2013. My truck was built October 2013 and Tom Wood Ford of Indianapolis Indiana states my vehicle…
The speedometer would intermediately stop working. When this is happening it would have a loss in power or begin to misfire. We have now stopped driving the vehicle because it down shifted extremely hard at road speed while along side another vehicle. The wife was extremely scared and I am afraid it will happen again and cause damage to the transmission.
The contact owns a 2014 Lincoln Navigator. The contact stated that while driving at various speeds, the vehicle would independently downshift which would lead to an abrupt slowdown of the vehicle. The contact stated that both the power train and fuel tank warning symbols would appear on the instrument panel after the failure. The contact would then restart the vehicle and resume normal driving…
The contact owns a 2014 Lincoln Navigator. The contact stated while driving 60 MPH, the transmission unexpectedly downshifted to a lower gear, and the vehicle decelerated to 25 MPH within 4-5 seconds. The power train warning light was illuminated. The contact pulled over to the side of the road and turned off the vehicle. The contact stated that upon restarting the vehicle, the warning light was…
Transmission shutting
Had powertrain trouble with your 2014 Lincoln Navigator?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the powertrain problem on the 2014 Lincoln Navigator?
It's a documented issue but not catastrophic. 7 complaints have been filed. Repairs average $2,500 and most owners catch it before it causes a breakdown.
At what mileage does the powertrain typically fail?
Based on the 7 complaints filed, powertrain issues most often appear around 87,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $2,500 for powertrain repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to powertrain?
No active recalls currently cover powertrain issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2014/Lincoln/Navigator.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.