2015 RAM 5500 owner complaints

Intake air grid heater nut came off and blew the #6 piston and engine needs to be replaced.

Vehicle was taken to the dealership due to an issue where white smoke would appear when the engine is under load. Dealer was unable to repair the issue due to scheduling conflicts. Owner attempted to drive the vehicle to another location for diagnostics. Vehicle caught on fire on the way to another dealer location.

Tl* the contact owns a 2015 Ram 5500. Upon inspection, the contact noticed coolant leaking from the vehicle. The vehicle was taken to fields Chrysler Jeep Dodge-sanford (750 towne center blvd, sanford, fl), but a leak could not be found. Afterwards, the low coolant indicator illuminated. The contact checked the engine compartment and noticed that coolant spewed out onto the undercarriage and electrical wiring. The local dealer (brewbaker Dodge Chrysler Jeep Ram of prattville, 2209 cobbs Ford rd, prattville, al) diagnosed that the water pump was defective and needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to orlando Dodge Chrysler Jeep Ram (4101 w colonial dr, orlando, fl) where it was initially diagnosed as muddy water on the motor. The fai

Vehicle is 2015 and has 44.4k miles on it. Had it in for a routine oil change and the mechanic showed me that the oil pan is in extremely poor condition with multiple rot spots all over and could fail at anytime. Mopar extended warranty covers oil pans, but they dont cover rust. An oil pan is a static part, the only way it could fail is from rust or a catastrophic engine failure where a connecting rod may protrude through it. Seems to be a common problem with these oil pans failing at a high rate. I have a 1977 chevy 289k miles with no problems on that oil pan. Perhaps the metal used in production was of poor quality which caused premature and expedited corrosion.

Truck was on highway going 70 MPH. Driver said it started shaking very hard and then heard a very loud bang. Was able to keep it under control and bring it to a stop. There were parts of the transfer case all over the road. Drive shaft was bent at a 45 degree angle. Wiring was wrapped around yoke, underneath of cab is damaged, brake system damaged, DEF system damaged, along with other problems that cant be seen.

Have had shifting issue's in the past, repair under warranty was trans solenoids. Now, out of warranty, it's the trans wiring harness.

The contact owns a 2015 Ram 5500. The contact stated while driving 69 MPH, the vehicle started vibrating abnormally with abnormal sounds coming from the vehicle. There was no warning light illuminated. The contact was able to park on the side of the road, exited the vehicle, and noticed transmission fluid leaking underneath the vehicle. The contact stated that the transfer case was fractured. The contact was unable to restart the vehicle. The contact stated that the fuel rail, Service 4-WD, and the braking system messages were displayed. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that the transfer case needed to be replaced. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been infor

The DPF filter is saying that its clogged and it won't regin. Codes: p0234, p24a2,p0420,p0087,p2228,p1193,p243f,p0102,p203f,p2280

Battery saver mode msg appeared on dash. Truck had 87,000 miles and 2400 hours. Used as a roadside service wrecker. Tested batteries. 1 tested bad. Replaced both batteries. Message comes back at startup on cold mornings. Msg stays on until truck is warmed later in the day.

Steering drag link broken off on passenger (long arm) side of adjustment sleeve. No impact damage. Part appears to have been improperly manufactured. Only approx 1/3 to 1/2 of the rod was fused together (see picture). Vehicle was backing up and turning in a parking lot, slightly downhill with service brakes lightly applied. Vehicle is heavily loaded (electrical bucket truck)

While traveling on a highway at speeds in excess of 50mph the 2015 Ram 5500 lost the rear set of dual tires on the passenger side. The wheels came off after all 10-wheel studs failed and broke off. This is the second incident on this same truck despite going through the warranty process and procedures through Stellantis/Ram. No incident or injuries resulted from the failure.

Front tires. Tires wear uneven. Mostly passenger side. Cupping of of both. Noticeable vibration. Same thing happened with my 2011 model of the same vehicle.

Front tires uneven wear, tire cupping. Vibration and noisy!