For this vehicle, the EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been extended to 15 years/150,000 miles, from the original 10 years/120,000 miles, as determined from the original in-service date. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusion criteria that apply to the BMW New Vehicle Limited Warranty. Vehicles that are registered in California or a State that has fully adopted the State of California PZEV(SULEV) emission regulation (State of registration, model, and model year dependent), the emission-relevant coverage for this component is 15 years/150,000 miles.
full bulletin at NHTSA ↗2016 BMW X1 engine problems
moderate Owners of the 2016 BMW X1 have filed 5 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
5
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2016 X1 (this page) | 5 |
| 2017 X1 | 11 |
| 2018 X1 | 6 |
When does it fail?
Of the 5 engine complaints filed for the 2016 BMW X1, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA engine complaint has been filed on this vehicle in over 5 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
full bulletin at NHTSA ↗Vehicle exhibits a slight acceleration delay when taking off from a MSA (automatic engine start-stopfunction) stop.
full bulletin at NHTSA ↗During a vehicle inspection and/or while addressing a customer's concern, the engine stabilizer bar/link appears to be worn.
full bulletin at NHTSA ↗During load reversal or taking off from a stop, there is a creaking or droning noise heard from the lower engine area.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 1 most recent
The engine mounts have failed on my car. I have only 14 thousand miles on the auto and do only city driving. Had this not been discovered during a routine oil change the results could have been catastrophic. There may be a problem with either the mounting hardware or the weight of the engine,
Had engine trouble with your 2016 BMW X1?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2016 BMW X1?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 5 complaints filed, engine issues most often appear around 38,667 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2016/BMW/X1.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.