Some 2015-2018 F-150, 2017-2018 F-Super Duty, 2018 Expedition/Navigator vehicles equipped with a vista roof opening panel may exhibit binding while opening or closing of the movable glass panel. The roof opening panel glass brackets are available for service. Both brackets must be replaced, FL3Z-1651070-A right side and FL3Z-1651071-A left side. Refer to Workshop Manual (WSM), Section 501-17 for removal and installation procedure. For claiming, use causal part 1651070 and applicable labor operations in section 12 of the service labor time standards (SLTS) manual.
full bulletin at NHTSA ↗2017 Ford F-450 body problems
moderate 6 complaints filed with NHTSA · avg repair $1,500 · see body across all vehicles →
Complaints
6
Recalls
0
Avg fix
$1,500
When does it fail?
Of the 6 body complaints filed for the 2017 Ford F-450, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Body accounts for 30% of every owner complaint on file for this vehicle — the dominant problem area across 3 categories tracked.
No new NHTSA body complaint has been filed on this vehicle in over 6 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering body on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 6 most recent
Tailgate to truck has opened 3 times while driving between september and november 2019. I am not sure at the exact time and conditions that the tailgate opened but weather was raining mid-day on two of the occasions, the third was early morning. One of the times the tailgate opened was while towing a cargo trailer which resulted in damage to the top of the tailgate as it fell on the trailer…
Tl* the contact owns a 2017 Ford f-450. While driving 10 MPH and hauling a trailer, the contact attempted to make a hard right turn when, without warning, the tailgate disengaged and fell to the ground. The tailgate was destroyed. The vehicle was towed to the contact's residence. The vehicle was not diagnosed or repaired. The dealer and manufacturer were not contacted. The failure mileage was…
Tailgate opens in transit and allows contents of bed to fall out of vehicle causing issues for drivers behind truck
Brought my truck into the Ford dealership because the door was not latching closed at all. The truck is still under warranty and has less than 20k miles. Later that day the dealership called and told me the truck was fixed and ready to be picked up. Less than 48 hours later the latch again would not work. I drove the truck back to the dealership while holding the door closed with one hand…
Tl* the contact owns a 2017 Ford f-450. The contact stated that while driving there was a loud crunching sound and became aware that the tailgate had fallen onto the trailer. The vehicle was taken to shawnee mission Ford (11501 shawnee mission pkwy, shawnee, ks 66203) where they informed the contact that a previous recall repair was performed correctly. The vehicle was then taken to thoroughbred…
Tl* the contact owns a 2007 Ford f-450. While attempting to drive the vehicle, the front and rear driver's side and the rear passenger door failed to lock when the temperature got cold. The contact called siemans Ford at (269) 465-5344 (located at 8961 red arrow hwy, bridgman, mi 49106) and was informed that there was no remedy for the vehicle doors. The manufacturer stated that they knew about…
Had body trouble with your 2017 Ford F-450?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the body problem on the 2017 Ford F-450?
It's a documented issue but not catastrophic. 6 complaints have been filed. Repairs average $1,500 and most owners catch it before it causes a breakdown.
At what mileage does the body typically fail?
Based on the 6 complaints filed, body issues most often appear around 37,925 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,500 for body repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to body?
No active recalls currently cover body issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2017/Ford/F-450.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.