2018 Ford Transit Connect owner complaints

Steering system failed while driving put driver at risk of crash. The problem still exists. It appears that the power steering rack has failed for the second time and will need to be replaced. There was no warning prior to failure

Power steering failed without warning while vehicle was being driven at highway speeds. Vehicle required replacement of power steering rack. This is the 4th time this has happened with my Ford Transit Connect vans

Unexpected power steering failure while driving. Driver and surrounding vehicles at risk Ford Dealer has reproduced the problem but can't identify the cause There weren't any warning lamps or messages before failure I own two other Ford Transit Connect vans from 2018, each has had the same problem

Power steering failure while driving Driver safety at risk as well as surrounding vehicles yes yes no warning lights, messages or other symptoms prior to failure

Power steering failed without warning. Rack and pinion had to be replaced. You now have 5 complaints on this but still no investigation open. This is clearly a manufacturer defect. $2,700 to fix. Vehicle only had 65,000 miles on it when it failed.

The contact's company owns a 2018 Ford Transit Connect. The contact stated that while an employee was driving at 30 MPH, the rear driver side sliding door unintendedly opened. The employee could not shut the door due to a defective latch. The contact stated that a zip tie was used to secure the door. The vehicle was not diagnosed or repaired. The manufacturer nor the dealer had been notified of the failure. The vehicle was not repaired. The failure mileage was approximately 80,000.

hello - this is not a safety issue with my car. for the moment. inputting the VIN it states that there is only 1 row of seats (D/P). this is not accurate. there are 3 seat rows in my van. (front x2, middle x3 and rear seats x2) total of 7 seats. thus this should be corrected for my VIN. if or when i have a complaint about the safety of the seats, belts, head rests etc... it will make sense. i do not have a cargo van. it's a seven passenger seat van.

My vehicle is less than 5 years old, 10 months out of warranty. The LOCKS stopped working. They made the noise, but no action. So, I thought the locks were still working. The dealership had no idea what the issue was - they've had my vehicle for almost a month trying to figure it out. So far they've changed the Body Control Module and are getting another part. Ford will do nothing even though Locks should be something always covered or at least for 5 years. No warnings. This put me at risk as I camp in the vehicle and didn't know it wasn't locking (because it made the noise like it was).

The transmission is having a shuddering issue, and looking online there on tons and tons of people having the same issue and stating it’s the torque converter and this is over many different years and variants of my vehicle… how is this not a recall yet?? People are having this issue right after purchase?

I had been driving my car for a few minutes when I heard a loud pop and my rear window glass shattered. Covered in spider glass cracks and only held in place by the tint. No point of impact visible to show that it had been hit by an object. It was chilly, 43 F, and I had the heat/defrost on. Unfortunately, when arriving to work, I opened my sliding door look at the damage from the inside and doing so caused glass to fall out, so I have no picture of just the glass the way it was when it broke. A quick search shows this has happened to other vehicles including transit connects like mine, and caused by the heated glass.

Vehicle is equipped (standard equipment, not an option) with automatic folding side view mirrors on drivers door and passenger door. Safety fault is that vehicle can be started and driven with the vehicle in folded position. Ford dealership and Ford's customer hotline are claiming that this is normal operation of these mirrors. However, common sense dictates that a vehicle should not be able to be driven with the mirrors folded. Legally, this appears to be in violation of us DOT regulation cfr 571.111 s5.2.1 which relates to the field of view requirements for the outside rearview mirror - driver's side. If the mirror is folded, it does not meet that regulation. As such, the manufacturer coding of the folding system's hardware should always default to full open position when the vehic

The contact owns a 2018 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 24V294000 (Visibility); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that two dealers were made aware of the issue and informed the contact that there were no technicians at the dealer capable of performing the recall repair. The contact was promised a call back once a technician was able to service the vehicle. The manufacturer was made aware of the issue and referred the contact back to the dealer. The contact had not experienced a failure. Parts distribution disconnect.

Driving at higher speeds when going to brake, the vehicle drops gears and slows agressively. It started to do this occasionally a couple of month ago, now it happens every other day.

Torque Converter failed. Confirmed by dealer service department. No warning indicators. Dealer repaired under warranty but it took 3 months from the first phone call. Looking online at user boards this should be a recall issue. I was told I could continue to drive it until parts came in and only found out later that the transmission could be damaged by doing so.

The contact owns a 2018 Ford Transit Connect. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted, with the traction and ABS warning lights illuminated. The vehicle was able to be restarted; however, the failure recurred. The contact also stated that while the vehicle was parked, the contact became aware that transmission fluid was leaking from the transmission. The dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 114,000. The VIN was not available.

ABS brakes are locked up and only release after a few seconds. I have replaced the driver front caliper and now the passenger front is locking. After a quick search online, I have found several cases of the ABS module malfunctioning on this vehicle requiring a new module and programming. The first time the driver side locked, there were no warning lights and when I arrived home, the rotor was glowing red. Could have caused a fire.

Component Affected: Service Brakes / ABS Module / Hydraulic Braking System Description of Safety Defect: There is an active, intermittent, catastrophic failure in the front braking system/ABS module causing the front brakes to completely lock up mid-transit while operating at high speeds (60+ MPH). First Incident (April 24, 2026): During operation on a busy interstate at over 60 MPH, the front braking system experienced a sudden, catastrophic thermal lock-up. This caused violent vehicle shuddering, extreme friction heat, and heavy, thick, acrid smoke. The vehicle was brought to a dealer shop for repair. Second Incident (April 29, 2026): Four days after delivery, the identical catastrophic brake lock-up recurred mid-transit, creating an immediate fire hazard due to friction heat and smoke

Loud noise w/vibration and foul odor coming from heater blower. Dealership discovered a rodent's nest in the climate control blower motor. Dealership indicated that there is no remedy to prevent recurrence. Dealership also mentioned that the Ford escape has a history of the same problem. See Ford's tsb 17-0034, published 3/21/17 re Ford's recommended prevention: "...install the new inlet duct gasket with screen..." (emphasis added).

Driver's side front low beam bulb burns out continuously

ABS light comes on as well as loss of traction control and hill assist. Steering is more difficult, and the speed ohmmeter will not work. This is the second time this has happen. First time mechanic replaced bad speed sensor on drivers' side front wheel and everything went back to normal it only had around 6K miles on it. Now it has around 7.5K on it and it has happen again. Have not taken it in for repair yet.