This service bulletin provides information on replacing the intake manifold when the engine is replaced after severe internal engine damage.
full bulletin at NHTSA ↗2019 Chevrolet Sonic engine problems
moderate 3 complaints filed with NHTSA · avg repair $3,100 · see engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
When does it fail?
Of the 3 engine complaints filed for the 2019 Chevrolet Sonic, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Of the 7 model years of Chevrolet Sonic we track for engine problems, this one has the fewest owner complaints on file (3).
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
full bulletin at NHTSA ↗This service bulletin provides information to dealership personnel for new vehicles with less than 1,000 miles that may not pass California smog inspection or smog inspection in other states.
full bulletin at NHTSA ↗This warranty administration bulletin provides policy information on vehicles outside of a California Emissions State who move to and register their vehicle in a California Emission State may be entitled to the 7 year, 70,000-mile Emission Select State Component Limited Warranty.
full bulletin at NHTSA ↗This bulletin advises the technician to flush the cooling system multiple times if oil has been found in the cooling system and replace the parts that may be contaminated due to oil in system.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
The contact owns a 2019 Chevrolet Sonic. The contact stated while pulling into the garage, the high engine temp warning light illuminated, and the engine was overheating. The contact immediately turned off the vehicle. The contact stated there was coolant underneath the front of the vehicle. The contact had learned that the water pump failure was common for the vehicle and believed that the water…
The contact owns a 2019 Chevrolet Sonic. The contact stated the RPMs rose abnormally high. The contact stated that the check engine warning light had illuminated. The vehicle was taken to an AutoZone where it was scanned and diagnosed that the turbo charger had failed and needed to be replaced. The diagnostic scan retrieved DTC code: P0299. The manufacturer was made aware of the failure. The…
There is no temperature indicator and the car overheats. This caused the hose to the coolant to leak. I had the housing unit replaced but then the car still ran hot. I had the get the whole thermostat replaced. No forum could assist with the replacement of the 2019 as if this year model doesn’t exist and the part needed doesn’t fit properly making my car inoperable.
Had engine trouble with your 2019 Chevrolet Sonic?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2019 Chevrolet Sonic?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 3 complaints filed, engine issues most often appear around 64,500 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2019/Chevrolet/Sonic.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.