This bulletin provides best practice recommendations when performing brake service procedures.
full bulletin at NHTSA ↗2019 Hyundai Santa Fe brakes problems
severe Owners of the 2019 Hyundai Santa Fe have filed 7 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
Complaints
7
Recalls
0
Avg fix
$450
| Model year | brakes complaints |
|---|---|
| 2015 Santa Fe | 23 |
| 2016 Santa Fe | 12 |
| 2017 Santa Fe | 43 |
| 2018 Santa Fe | 15 |
| 2019 Santa Fe (this page) | 7 |
| 2020 Santa Fe | 6 |
| 2021 Santa Fe | 4 |
| 2022 Santa Fe | 5 |
| 2023 Santa Fe | 16 |
1crash
1fire
1injury
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
full bulletin at NHTSA ↗Certain 2019-2020MY Santa Fe and 2018-2020MY Elantra equipped with front camera/multi-function camera may exhibit a series of Lane Keep Assist System (LKAS), Front Collision Avoidance Assist (FCA), High Beam Assist (HBA), Smart Cruise Control (SCC), and Autonomous Emergency Braking (AEB) warnings and function conditions on the instrument cluster. This bulletin describes the procedure to replace the front camera/ multi-function camera.
full bulletin at NHTSA ↗If you are servicing an applicable vehicle with a âCheck Engineâ light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and oil pressure harness.
full bulletin at NHTSA ↗This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). The rear wheel speed sensor is available as a separate service part from the rear wheel hub assembly. When appropriate, it is recommended to replace only the rear wheel speed sensor instead of the full assembly.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 1 most recent
Overly excessive oil consumption 2 Quarts every 3 or 4 days.no leaks. Engine gets so hot I don't have to turn on heater In winter. On going issue since 100,000 miles. EBS light stays on electronic parking brake switch does not work. Parking brake will randomly engage after vehicle is turned off. Dealership cannot duplicate issue. If cruse control is turned on the vehicles warning lights all of…
Had brakes trouble with your 2019 Hyundai Santa Fe?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2019 Hyundai Santa Fe?
It's a meaningful issue. 7 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $450.
At what mileage does the brakes typically fail?
Based on the 7 complaints filed, brakes issues most often appear around 29,714 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2019/Hyundai/Santa Fe.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.