Oil Consumption Measurement and Electronic Oil Consumption Measurement
full bulletin at NHTSA ↗2020 Volkswagen Passat engine problems
moderate Owners of the 2020 Volkswagen Passat have filed 3 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of September 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2016 Passat | 10 |
| 2017 Passat | 3 |
| 2018 Passat | 6 |
| 2020 Passat (this page) | 3 |
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Lubricating engine components before reassembly.
full bulletin at NHTSA ↗Instruction, how to lubicate engine before initial start.
full bulletin at NHTSA ↗Volkswagen Engine Oil Standards
full bulletin at NHTSA ↗This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the error message ERP0204E could occur during perform initial operation, software configuration, SVM updates for any control module(s) etc.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
Oil pressure sensor fails. Causing high oil pressure. Causing the valve cover to be destroyed and the oil pan to leak. Draining the car oil.
The contact owns a 2020 Volkswagen Passat. The contact stated while driving at various speeds, the vehicle made abnormal sounds. The contact stated that the vehicle started independently, and the Driver Assist function engaged independently. Additionally, the contact stated that the vehicle was swerving unintendedly and would vibrate while driving. The vehicle was taken to the dealer several…
Bought car from dealer. Vw Manhattan. 42000miles. 8 months later at 53000 miles. Engine problems. Went to Vw service. Head gasket. Lemon car. Warranty till 50000 miles. Cost? 4800$ Worse car possible.
Had engine trouble with your 2020 Volkswagen Passat?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2020 Volkswagen Passat?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2020/Volkswagen/Passat.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.