2021 Ford Bronco owner complaints

The vehicle will throw a warning saying the cross trafic collision is in operable. A ford tech looked at it and said a wiring harness is chaffed causing blind spot monitioring and cross traffic collision systems to not work. Cost of the part only is $700, not including labor. this is a very serious fault, which could result in injury and fatalitys

A serious safety recall advised in July of 2025 still has not been fixed.

Rear glass lift gate exploded. Wind advisory was in effect but no surrounding cars were disturbed. The vehicle was parked and fully secure.

Ford has 3 safety recalls on 2021 ford bronco and they have no remedy to fix any of them yet. My car stalled out 3 times now because of the low pressure fuel pump failure recall. I was pulling out into traffic and it stalled out while a car was coming at me. The only solution Ford had was to put old parts in the car which I refused. I asked for a loaner vehicle and they said they don’t have any. Recall warning is going on 6 months. I am at a risk and other people are at a risk having my car on the road, tried lemon law and Ford denied me. Nobody feels safe in my car and someone is going to get seriously hurt if this happens at the wrong time.

The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 23V598000 (Back Over Prevention) however the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

water is leaking from the passenger side roof through the passenger side door airbag when it rains. The passenger side top door airbag is constantly getting wet from this leak as water passes through.

I am writing to report a serious safety issue with my 2021 Ford Bronco. While driving on the highway at approximately 55-60 mph in the early morning, I heard a loud noise and saw powder falling on me. Upon pulling over, I discovered that a large section of my hardtop had blown off. Specifically, the plastic part over the fiberglass detached. If there had been a car behind me, it would have certainly been struck by the debris. This incident poses a significant danger not only to me but to other motorists as well. Ford is aware of this issue but has refused to address it. I consider this a critical safety hazard and request that this matter be investigated promptly. I believe the manufacturer should replace the defective hardtop and take responsibility for ensuring the safety of their vehicl

The contact owns a 2021 Ford Bronco. The contact stated after the vehicle was parked in the rain, he noticed on the passenger’s side A-pillar, where the air bag marking was located that water was leaking into the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer where the cause was discovered as a clip was damaged allowing the water to get into the A-pillar. The dealer repaired the failure by adding additional sealant to the area. The contact stated he looked at the repair and contacted the dealer stating the repair was not proper. The dealer informed the contact that a TSB was recently issued for the failure. The contact was waiting for an appointment as parts needed to be ordered to repair the failure. The manufacturer was notified, and a case was opened. T

Four hours into a drive today, going down a fairly steep hill @ ~30mph into a 4 point intersection my Bronco lost all power, brakes and steering. I mean it had nothing. We barely made it thru the intersection because the cars coming directly at us slammed brakes. I had no control and went off the road into someone’s yard, barely missing their fence. It was the scariest thing we’ve ever encountered. My son in the back screaming STOP at the top of his lungs is burned in my brain. What makes all of this worse is that Ford just had it in the shop for 3 days because the week before when they had my Bronco in the shop for yearly inspection/oil change and under their care it had the first symptoms of this issue. I received an app notice of a battery failure AND at their request because of this

Location of wiring from the factory for Blind Spot Warning and Cross Traffic Alert systems is not protected. The wiring has frayed and broken due to the wiring being unprotected, loose and rubbing on the rear bumper, causing the systems to not function. This is a blatant design defect from the factory, causing two safety systems to fail. Reporting now as, to the best of my knowledge, the manufacturer has not issued a TSB or recall and dealerships have acknowledged the issue.

2021 Ford bronco miles: 34,247 both rear calipers on the inside "locked" and caused irregular pad wearing on the inside. I am concerned the root cause may be a caliper issue or electronic brake issue not releasing the brake components. Rear outside brake pads at 80% rear inside brake pads at 2% vehicle first looked at by a local mechanic 3 weeks ago. Ford diagnosed the issue today 11/27/24. There was one warning 2 weeks ago that the brake was faulty and to contact a dealership immediately. The rear brakes are necessary to safetly stop the vehicle. I am concerned that I will need to continually need to monitor the rear brake components regularly in order to safely operate my vehicle or that the calipers will "stick" again causing the issue to be ongoing. Way scarff Ford currently has the

The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle was bouncing. Additionally, the rear-end swayed while driving over a bump. The dealer was made aware of the failure but confirmed that parts were on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 40,000.

The contact owns a 2021 Ford Bronco. The contact stated that the passenger’s side rear shock was blown. While driving 35 MPH over a bump in the road, or while driving over a wet surface, the rear of the vehicle was fishtailing. There was oil leaking from the shock. The contact had a nail in the tire, and after removing the wheel, the contact became aware that the shock was covered in oil. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was determined that the rear shocks needed to be replaced. The vehicle was not repaired due to the parts being on back order. The manufacturer was made aware of the failure. The approximate failure mileage was 60,000.

The contact owns a 2021 Ford Bronco. The contact received Manufacturer recall number: 21C23 (Air Bags), NHTSA Campaign Number: (Awaiting) however, the dealer informed the contact that the parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and informed the contact that the remedy was not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 21V770000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Brake Light issue: Red Brake Light appears when driving over 40 MPH. To fix issue Tube Vacuum had to be replaced. Part# MB3Z 2420 This seems to be an on going issue with 2021 Broncos.

The contact owns a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, she depressed the accelerator pedal however, the engine failed to engage, and the vehicle stalled. The vehicle was towed to the contacts residence. No warning lights was illuminated. The vehicle was not diagnosed or repaired. The dealer was notified, and the contact was scheduled and appointment for the following month. The manufacturer was not notified of the failure. The failure mileage was approximately 6,000.

The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 23V069000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

This issue occurs anytime the wipers are used, including rain, snow, sleet, etc.. The issue has been present from day 1 of ownership and continues to this day. Wipers are turned on to any setting. After approximately 1 minute, the wiping will stop completely, then start wiping at approximately 4sec intervals (15 cycles per minute). This pace is almost always inadequate to provide unobstructed visibility. This pace does not meet the mandated requirements of FMVSS 104 section S4.1.1.3 (20 cycles per minute) and thus means the vehicle should deemed non compliant for on road use until corrected.

While driving in snowy conditions the headlights become covered with snow to the point of not illuminating enough to see. Which then makes trying to find a spot to pull over safely to wipe them becomes extremely dangerous. The snow covered lights happens quickly. Creating hazardous driving conditions. The data provided is the most recent. This happens every winter since purchasing this vehicle. I was not familiar with notifying your agency until recently.