Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
severe Owners of the 2022 Ford Expedition have filed 8 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
| Model year | brakes complaints |
|---|---|
| 2018 Expedition | 4 |
| 2019 Expedition | 3 |
| 2020 Expedition | 4 |
| 2022 Expedition (this page) | 8 |
| 2023 Expedition | 4 |
| 2024 Expedition | 7 |
| 2025 Expedition | 3 |
Of the 8 brakes complaints filed for the 2022 Ford Expedition, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
A loss of brake function increases the risk of a crash.
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
26C10 Recall remedy -Addresses instances where the trailer lights and trailer brakes may not function
full bulletin at NHTSA ↗2018-2022 Expedition/Navigator "Park Brake Limited Function Service Required" Message In The IPC
full bulletin at NHTSA ↗Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting, bluing/discoloration and/or heat spots. For additional information, refer to WSM section 206-00.
full bulletin at NHTSA ↗Priority Update 22-PU1010-MIL-LT for 2022 Expedition and Navigator vehicles is now available. Quality improvements include: -Electronic Brake Boost (EBB) interaction enhancement durring neutral tow operation. -Robustness change to brake fluid viscosity algorithm for low temperature compensation to prevent false DTC activation.
full bulletin at NHTSA ↗Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting, bluing/discoloration and/or heat spots. For additional information, refer to WSM section 206-00.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
The contact owns a 2022 Ford Expedition equipped with Hankook, Tire Line: Dynapro, Tire Size: 275/55/R20, DOT Number: (N/A). The contact stated that while the vehicle was parked, the contact became aware that the tire pressure was low. Additionally, the check engine warning light was illuminated. The contact drove to Discount Tire to inflate the tire. The contact stated that there was an abnormal…
Trailer brake controller is not engaging trailer brakes when the brake pedal is pressed. The trailer brakes will engage when manually squeezing the controller. Exact same symptoms as my 2021 f150 which had the recall. This is a September build, dealer service is telling me there is nothing wrong, it all checks out.
When slowing down to turn into a parking lot my car suddenly experienced sudden “phantom braking”. I was going slowly and I wasn’t braking. My car only has automatic braking when cruise control is on. Cruise wasn’t on. The car suddenly braked hard and chimed twice. My car has a collision warning system but that doesn’t chime like this. I didn’t see any dash warning lights, it looked normal by the…
It's a meaningful issue. 8 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $450.
Based on the 8 complaints filed, brakes issues most often appear around 22,033 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Yes — 1 active recall(s) cover brakes issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.