This bulletin supersedes 26-2194. Reason for update: update the Parts list to correct a part description " Loctite 638", update the claim quantity for the drain/fill plug, update the claim quantity of the wheel hub bolts (Corsair) and limited the parts list for Edge/Nautilus to only the rear drive unit fluid. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: Shudder chatter condition, most noticeable at low speeds turning No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.
full bulletin at NHTSA ↗2022 Lincoln Corsair powertrain problems
moderate Owners of the 2022 Lincoln Corsair have filed 4 NHTSA complaints about the powertrain at roughly $2,500 to repair (U.S. federal records, as of September 2026). Source: NHTSA Office of Defects Investigation. See powertrain across all vehicles →
Complaints
4
Recalls
0
Avg fix
$2,500
| Model year | powertrain complaints |
|---|---|
| 2020 Corsair | 4 |
| 2021 Corsair | 5 |
| 2022 Corsair (this page) | 4 |
When does it fail?
Of the 4 powertrain complaints filed for the 2022 Lincoln Corsair, here's the actual mileage breakdown — failures cluster heaviest at 75,000-100,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering powertrain on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Some 2020-2026 Corsair/Escape, 2021-2026 Bronco Sport, and 2022-2026 Maverick vehicles equipped with an 8F35 transmission may exhibit a shudder condition, most noticeable at speeds below 60 mph (100 km/h), with no relevant diagnostic trouble codes (DTC) stored in the powertrain control module (PCM). Sometimes, this may be perceived/felt as an engine misfire. This may be due to the torque converter. If Pinpoint Test K: Torque Converter Clutch Operation in Workshop Manual (WSM), Section 307-01 > Diagnosis and Testing > Diagnosis by Symptom directs to replace the torque converter, remove and replace the torque converter and torque converter seal. Refer to WSM, Section 307-01 > Removal and Insta
full bulletin at NHTSA ↗Some 2020-2026 Corsair/Escape, 2021-2026 Bronco Sport, and 2022-2026 Maverick vehicles equipped with an 8F35 transmission may exhibit a shudder condition, most noticeable at speeds below 60 mph (100 km/h), with no relevant diagnostic trouble codes (DTC) stored in the powertrain control module (PCM). Sometimes, this may be perceived/felt as an engine misfire. This may be due to the torque converter. If Pinpoint Test K: Torque Converter Clutch Operation in Workshop Manual (WSM), Section 307-01 > Diagnosis and Testing > Diagnosis by Symptom directs to replace the torque converter, remove and replace the torque converter and torque converter seal. Refer to WSM, Section 307-01 > Removal and Insta
full bulletin at NHTSA ↗This bulletin supersedes 25-2627. Reason for update: To add a Step to reprogram the all-wheel drive (AWD) module for Bronco Sport vehicles. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: Shudder chatter condition, most noticeable at low speeds turning No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.
full bulletin at NHTSA ↗Some 2020-2026 Escape and 2021-2026 Corsair vehicles equipped with a 2.5L engine may exhibit a fuel door that won't open with diagnostic trouble code (DTC) P04CA stored in the powertrain control module (PCM). This may be due to an open circuit on circuit SBB05 and/or a damaged splice S133. Before performing the pinpoint test for P04CA in Workshop Manual (WSM), Section 310-00, inspect circuit SBB05 and splice S133 for damage such as an open circuit. Repair as necessary. Refer to Wiring Diagram, Cell 005. If no damage is found, refer to WSM, Section 310-00 for normal diagnostics. For claiming use causal 14290 and labor operations 12650D, 12650D45, and 12650D45WR.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
After stopping vehicle at red light, drive thru, stop sign, when I try to accelerate a check engine light comes on and message power train malfunction/reduced power. The vehicle then has to be put in park, restart, and put back in drive. This happened when pulling out into road at a stop sign, and a busy red light. I feel this is a safety issue. I have taken the vehicle to Lincoln and they…
Several problems have occurred, not sure if they are related or not. The vehicle is available for inspection upon request. In my opinion as a retired mechanic the problem components might include transmission, torque converter, accelerator or any electrical components associated with these systems. There were no warning lamps or messages related to the situation before or since. The following are…
The contact owns a 2022 Lincoln Corsair. The contact stated that while driving at various speeds, the vehicle experienced severe, erratic shifting in all gears, transmission slippage, and hesitation. No warning light was illuminated. The vehicle was initially taken to an independent mechanic, where a transmission replacement was recommended. The vehicle was then taken to the dealer, where…
At around 125,000, my car developed a shudder at switching gears. Ford has previously identified a problem with my car, which was manufactured before XXX, and purchased on or around XXX. They have since sent out a Technical Service Bulletin (TSB25-2154). No diagnostic codes are identified for the car, but since my car's extended warranty expired at 100,000 miles, I have a potentially dangerous…
Had powertrain trouble with your 2022 Lincoln Corsair?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the powertrain problem on the 2022 Lincoln Corsair?
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $2,500 and most owners catch it before it causes a breakdown.
At what mileage does the powertrain typically fail?
Based on the 4 complaints filed, powertrain issues most often appear around 75,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $2,500 for powertrain repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to powertrain?
No active recalls currently cover powertrain issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2022/Lincoln/Corsair.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.