Warranty Instruction and guidance
full bulletin at NHTSA ↗2022 Volkswagen Passat brakes problems
moderate Owners of the 2022 Volkswagen Passat have filed 3 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
Complaints
3
Recalls
0
Avg fix
$450
| Model year | brakes complaints |
|---|---|
| 2018 Passat | 8 |
| 2022 Passat (this page) | 3 |
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Alignment sheet submission.
full bulletin at NHTSA ↗Brake Repair or Replacement Information
full bulletin at NHTSA ↗Brake repair or replacement instruction.
full bulletin at NHTSA ↗Brake Disc (rotor) instruction for resurfacing following Volkswagen Warranty Policy & Procedure Manual.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
In May of 2023, I reported that the driver side rear brake caliper appeared to be sticking as one pad at that corner was completely worn down and making contact with the rotor, while the other pad at that same corner had no visible wear. Dealer replaced the rear left rotor under warranty (40,805 miles). Warranty also covered both rear rotors and rear pads due to rotor damage. In February of…
Brakes are on this care are failing well in advance of typical cars. My car's rear brakes are measuring at a 2 with just over 20,000 miles on the vehicle. When we asked the dealership about this, they said the Passat is just "hard on rear brakes." We had a previous Passat and did not experience this issue. This is unsafe and unreasonable to expect these brakes wearing out at less than half of…
I am reporting what appears to be a serious, chronic safety issue with this vehicle (not just this particular car, but all M/Y 2020~2022 (and possibly 2012~2019 as well if they use the same brake components). Since new, my car has had chronic brake problems and these ongoing issues keep arising, pointing to defective brake caliper design. They have not caused an accident (for me anyway), but…
Had brakes trouble with your 2022 Volkswagen Passat?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2022 Volkswagen Passat?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $450 and most owners catch it before it causes a breakdown.
At what mileage does the brakes typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2022/Volkswagen/Passat.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.