Some 2021-2023 Explorer vehicles equipped with a 3.0L EcoBoost engine, 2021-2023 Aviator vehicles equipped with a 3.0L EcoBoost or 3.0L plug-in hybrid electric vehicle (PHEV) engine, 2021-2023 Edge/Nautilus vehicles equipped with a 2.7L EcoBoost, 2021-2024 F-150 vehicles equipped with a 2.7L EcoBoost, and 2021-2024 Bronco and 2024 Ranger vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine. This noise may occur on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. This may be due to an internal component of the variable cam timing (VCT) unit. Workshop Manual (WSM)
full bulletin at NHTSA ↗2023 Lincoln Aviator engine problems
moderate Owners of the 2023 Lincoln Aviator have filed 4 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
4
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2020 Aviator | 4 |
| 2021 Aviator | 4 |
| 2023 Aviator (this page) | 4 |
When does it fail?
Of the 4 engine complaints filed for the 2023 Lincoln Aviator, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Some 2021-2024 Edge/Nautilus, 2021-2025 Bronco/Bronco Sport/E-Series/Escape/Corsair/Expedition/Navigator/Explorer/Aviator/F-150/F-Super Duty/Mustang/Ranger, and 2022-2025 Maverick vehicles may require an A/C compressor clutch assembly replacement be performed for various concerns. Workshop Manual (WSM), Section 412-00 Removal and Installation has been updated to eliminate the need to remove and install the A/C compressor to change out the A/C Compressor clutch assembly.
full bulletin at NHTSA ↗Some 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
full bulletin at NHTSA ↗This TSB supersedes TSB 22-2377 to update the vehicle model years affected and Parts List. Some 2020-2023 Explorer vehicles equipped with a 3.0L EcoBoost engine or 2020-2023 Aviator vehicles equipped with a 3.0L EcoBoost or 3.0L PHEV engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. This may be due to a worn VCT unit. To correct the condition, follow the Service Procedure to replace the VCT units
full bulletin at NHTSA ↗For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
This vehicle continues to randomly stall upon acceleration from a dead stop. There have been numerous times this has created a near- miss accident. It has been in for service on several occasions since owning it with no resolve. This issue has been ongoing since owning it and only getting worse. Current mileage is approx 23,000 miles.
The contact owns a 2023 Lincoln Aviator. The contact stated that after parking the vehicle in the garage, the garage became extremely hot, and the fans underneath the vehicle activated. The contact opened the garage. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the…
I did an inspection of my exhaust system and saw numerous carbon deposits along both pipes at different joints. I brought this to the attention of the dealer and they repaired only one (1) leaking joint at the tailpipe. They told me the other leaking joints are normal and are of no concern. I have a video, pictures and the dealer inspection/repair forms from two (2) different service dates.
2023 Lincoln Aviator was accelerating out of Toll booth to 70mph. Upon acceleration the engine hiccupped but continued to operate. Approximately 2 miles later the low oil pressure indicator and low battery indicator popped up, no prior indications existed. Vehicle stalled within 0.5 miles as I was assessing what to do and to pull off to a safe place. I had the vehicle towed to the dealer at…
Had engine trouble with your 2023 Lincoln Aviator?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2023 Lincoln Aviator?
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 4 complaints filed, engine issues most often appear around 20,990 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2023/Lincoln/Aviator.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.