Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2024 Ford Bronco body problems
moderate
Owners of the 2024 Ford Bronco have filed 12 NHTSA complaints about the body at roughly $1,500 to repair (U.S. federal records, as of November 2026). Source: NHTSA Office of Defects Investigation.See body across all vehicles →
Of the 12 body complaints filed for the 2024 Ford Bronco,
here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
0 (0%)
25-50k
1 (100%)
50-75k
0 (0%)
75-100k
0 (0%)
100-125k
0 (0%)
125-150k
0 (0%)
150k+
0 (0%)
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted.
Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits
and driving conditions shift the curve as much as mileage alone.
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles
A detached fender flare can become a road hazard and increase the risk of a crash.
Fix: Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Owner notification letters were mailed September 1, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering body on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service BulletinSSM 55301Oct 2026
Some 2021-2026 Bronco vehicles equipped with a hard top may exhibit water leaking between the back glass and hard top. This may be due to dirt and/or debris build up between/on the liftgate window glass seal and/or back glass. To correct this condition, use an approved cleaner according to the Owner's Manual to clean the back glass and/or hard top rear cap seal and check for water leaks again. If water leaks are still present, refer to Workshop Manual (WSM), Section 501-18B for normal diagnostics and repair as necessary outside of this article. For claiming, use causal part 78205G61 and labor operation MT55301SSM up to 0.5 hours.
This article supersedes TSB 25-2575 to update the Parts list to add the applicable body wiring harnesses and underbody shield bolts. Some vehicles listed in the Model statement above may exhibit a "Sta-bar Disconnect Service Required" message in the instrument panel cluster (IPC) with any of the following diagnostic trouble codes (DTCs) stored in the chassis control module (CHCM): C103A, C1A99, C1B03, C1B07, C1B14 and/or B1A67. This may be due to water intrusion in the stabilizer bar wiring harness connector.
Some of the following vehicles: * 2023-2025 F-Super Duty built on or before 02-Feb-2025 * 2024-2026 Ranger/Bronco/Mustang * 2024-2025 F-150 built on or before 15-Jul-2025 * 2024-2025 Nautilus built on or before 16-Feb-2025 * 2025 Explorer/Aviator built on or before 01-Feb-2025 may exhibit all of the following symptoms: - "No Key Detected" message displayed on the instrument panel cluster (IPC). - Key fob does not work in the backup slot. - Remote keyless entry (RKE) (lock and unlock from the key fob) functionality will work to lock/unlock the vehicle. If the vehicle exhibits these symptoms, start the vehicle using both key fobs. If the no crank/no start condition with "No Key Detected" conce
Some 2021-2026 Bronco vehicles may exhibit a "Park Brake Limited Function Service Required" message in the instrument panel cluster (IPC). This may be due to an issue with the driver door harness connector after removing and installing the removeable doors. If diagnostic trouble code (DTC) B1625:29 is stored in the driver door module (DDM), inspect connector C322C between the upper and lower door hinges that attaches to the body for proper installation and/or pin fitment. Repair as necessary. If the condition was caused by improper door installation, do not submit a claim for this condition. If no concerns are found with the connector, refer to Workshop Manual (WSM), Section 501-11 > Diagnos
This article supersedes 25-2551. Reason for update: to correct the descriptions for the liftgate glass weather seals. Some of the vehicles listed in the model statement above may exhibit paint wearing along on the top inner edge of the tailgate where the rear window weather strip contacts the tailgate. This may be due to the accumulation of dirt between the rear window seal and tailgate.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
3 most recent
body
· filed 12/21/2024
There are multiple spots on a 2024 4-door Outer Banks Bronco (purchased in 03/2024) that are melted. Most of the plastic components of the exterior body of the Bronco are bubbled, warped, or the paint is peeling away from the plastic. See affected areas listed below (see also photos attached). Areas Affected: -entire rear side of hard top, including 3rd brake light mount -passenger front mirror…
body
· filed 10/30/2026
My hardtop has been replaced once and the replacement is now cracking.
body · 45,500 mi
· filed 10/29/2026
The contact owns a 2024 Ford Bronco. While walking around the vehicle, the contact discovered that the roof had delaminated and was cracked in several places, allowing rainwater to enter the vehicle. There was no impact to the roof to cause the cracks. The vehicle was taken to the dealer, and the dealer photographed the damages to submit a claim to the manufacturer. The manufacturer was notified…
Had body trouble with your 2024 Ford Bronco?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the body problem on the 2024 Ford Bronco?
It's a documented issue but not catastrophic. 12 complaints have been filed. Repairs average $1,500 and most owners catch it before it causes a breakdown.
At what mileage does the body typically fail?
Based on the 12 complaints filed, body issues most often appear around 45,500 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,500 for body repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to body?
Yes — 1 active recall(s) cover body issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2024/Ford/Bronco.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.