This bulletin provides information related to a Transmission Control Unit (TCU) software update for some vehicles equipped with an 8-speed wet dual clutch transmission (8WDCT). The software update revises the touch point learning variation, improving drivability and judder symptoms. Some 8WDCTs (indicated by a new part number) received an updated clutch spring. The correct TCU software update must be matched with the correct corresponding 8WDCT hardware, otherwise, drivability concerns may occur. This service procedure should be performed prior to any 8WDCT replacements done for drivability/judder concerns.
full bulletin at NHTSA ↗2024 Hyundai Sonata powertrain problems
severe Owners of the 2024 Hyundai Sonata have filed 6 NHTSA complaints about the powertrain at roughly $2,500 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See powertrain across all vehicles →
Complaints
6
Recalls
0
Avg fix
$2,500
| Model year | powertrain complaints |
|---|---|
| 2020 Sonata | 23 |
| 2021 Sonata | 21 |
| 2022 Sonata | 23 |
| 2023 Sonata | 15 |
| 2024 Sonata (this page) | 6 |
1crash
When does it fail?
Of the 6 powertrain complaints filed for the 2024 Hyundai Sonata, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering powertrain on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
The contact owns a 2024 Hyundai Sonata. The contact stated that while attempting to accelerate to overtake another vehicle at approximately 60 MPH, the vehicle unintendedly decelerated to approximately 20 MPH instead. The contact pulled over to the side of the road, turned off the vehicle for approximately 20 minutes, before restarting and continuing to drive. There were no warning lights…
After a dealer-installed software update on my 2024 Hyundai Sonata sel awd, the car began jerking during acceleration and shifting. This happens at low and moderate speeds and creates an unsafe hesitation, especially in traffic. This issue did not exist before the update. I believe the software update affected the transmission or engine control calibration. The dealership has not resolved the…
My car tends to jerk very hard two to three times on cold start up and I’ve read that the previous years have had this issue. They are still the same mechanically so I do not know why my year does not have a recall for it
Had powertrain trouble with your 2024 Hyundai Sonata?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the powertrain problem on the 2024 Hyundai Sonata?
It's a meaningful issue. 6 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $2,500.
At what mileage does the powertrain typically fail?
Based on the 6 complaints filed, powertrain issues most often appear around 16,500 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $2,500 for powertrain repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to powertrain?
No active recalls currently cover powertrain issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2024/Hyundai/Sonata.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.