TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. ?An ?Oil Pressure Low? warning message on the Multi-information Display (MID). ?A MIL ON condition with Diagnostic Trouble Codes (DTCs) P05202A (Engine Oil Pressure Sensor/Switch ?A? Signal Stuck in Range) and/or P052477 (Engine Oil Pressure Too Low [Severe]) present. Moisture from blow-by gases condenses and accumulates in the engine oil during short trips in extreme cold weather. When the moisture in the oil freezes, the oil pressure may drop, and the aforementioned warning indicators may displa
full bulletin at NHTSA ↗2024 Toyota Highlander brakes problems
moderate Owners of the 2024 Toyota Highlander have filed 5 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
Complaints
5
Recalls
0
Avg fix
$450
| Model year | brakes complaints |
|---|---|
| 2020 Highlander | 28 |
| 2021 Highlander | 47 |
| 2022 Highlander | 28 |
| 2023 Highlander | 14 |
| 2024 Highlander (this page) | 5 |
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
Ours has pulsing brakes and brakes feeling "off" at low speeds, potentially due to the interaction of regenerative and conventional braking. The brake pedal will also suddenly jolt the car forward when switching between braking systems. The system is unsafe.
There are many times over the course of the past few months where I am braking and the car lurches forward at least a few inches before coming to a complete stop. It feels as if it is being rear ended at a slow rate of speed. I have not been able to identify any pattern in this problem. It happens when I am braking to slow down at a faster rate of speed or when I need to come to a complete stop…
Brakes "let go" for a second or so when using. I have noticed this when coming to a stop sign at low speeds and especially if road surface is uneven. It does not happen all the time but it is very scary to suddenly lose the brakes! This puts others at risk because the car briefly speeds up when the brakes let go. It has happened at least twenty times while driving this SUV, most recently today.…
Brakes do not engage sometimes until brake is almost to floor. This has happened to the 3 people who have driven it and almost caused an accident. In fact the warning flashes on dashboard. Brakes have almost failed and yes, it is available upon request. Our safety was at risk because all 3 of us almost hit the person in front of us. The problem has not been reproduced by the 2 service places I…
Had brakes trouble with your 2024 Toyota Highlander?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2024 Toyota Highlander?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $450 and most owners catch it before it causes a breakdown.
At what mileage does the brakes typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2024/Toyota/Highlander.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.