The condition is for vehicles equipped with an accessory Power Port or Tire Inflator. During the installation process of the Power Port or Tire Inflator, the pre-wire connector is removed from the dummy cap (which is attached to the harness) and is left attached when power is connected. The purpose of the dummy cap is to prevent connector water intrusion/corrosion when the accessory is not installed.
full bulletin at NHTSA ↗2024 Toyota Tacoma body problems
moderate 5 complaints filed with NHTSA · avg repair $1,500 · see body across all vehicles →
Complaints
5
Recalls
0
Avg fix
$1,500
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering body on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Some 2024 – 2025 model year 4WD Tacoma and Tacoma Hybrid vehicles may exhibit a condition where the 4WD lights are flashing and a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: •P277111 – Four Wheel Drive (4WD) Low Switch Circuit Short to Ground •P178462 – 4WD/AWD Transfer Case Shift Motor Limit Switch and Transfer Case H4-L4 Position Switch Signal Compare Failure •P17AC62 – 4WD/AWD Transfer Case Shift Motor Limit Switch Signal Compare Failure The transfer case breather hose has been updated.
full bulletin at NHTSA ↗Some 2024 – 2025 model year Tacoma and Tacoma Hybrid vehicles equipped with an accessory roof rack may exhibit an abnormal vibration from the accessory roof rack while driving. New roof rack bumpers have been developed to address this vibration.
full bulletin at NHTSA ↗TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body dents/dings. ? Proper operation of electrical accessories (including interior light, clock, and radio reset). ? Interior cleanliness. ? Proper function of mechanical systems. Customer retention and proper maintenance of vehicles are, and have always been, a major focus for Toyota. To help remind customers that regular service is essential to the proper maintenance of the vehicle, dealers are required to install a service reminder sticker before delivery. By
full bulletin at NHTSA ↗An incorrectly sized seal can allow water or moisture to enter a connector on the Active Grille Shutter. This can cause the engine warning light to illuminate and/or the Active Grille Shutter to no longer open or close as designed.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 0 most recent
Had body trouble with your 2024 Toyota Tacoma?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the body problem on the 2024 Toyota Tacoma?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $1,500 and most owners catch it before it causes a breakdown.
At what mileage does the body typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $1,500 for body repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to body?
No active recalls currently cover body issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2024/Toyota/Tacoma.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.