Oil Consumption Measurement and Electronic Oil Consumption Measurement
full bulletin at NHTSA ↗2024 Volkswagen Tiguan engine problems
severe Owners of the 2024 Volkswagen Tiguan have filed 10 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of September 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
10
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2020 Tiguan | 17 |
| 2021 Tiguan | 40 |
| 2022 Tiguan | 67 |
| 2023 Tiguan | 18 |
| 2024 Tiguan (this page) | 10 |
1fire
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Lubricating engine components before reassembly.
full bulletin at NHTSA ↗Instruction, how to lubicate engine before initial start.
full bulletin at NHTSA ↗Volkswagen Engine Oil Standards
full bulletin at NHTSA ↗This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the error message ERP0204E could occur during perform initial operation, software configuration, SVM updates for any control module(s) etc.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 2 most recent
My car was less than a year old, had been at the dealership for routine maintenance on September 24th, and with no warning signals from the vehicle's electronics smoke started coming out from the hood while I was ~20 minutes into my drive to work. Within a short period of time there were flames, and ultimately the car was engulfed in flames, resulting in a total loss.
The contact owns a 2024 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated, though the vehicle had previously been serviced within 1,600 miles. The vehicle was taken to an independent mechanic, who informed the contact that the engine had consumed four quarts of oil within 1,600 miles. The contact was advised to take the vehicle…
Had engine trouble with your 2024 Volkswagen Tiguan?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2024 Volkswagen Tiguan?
It's a meaningful issue. 10 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $3,100.
At what mileage does the engine typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2024/Volkswagen/Tiguan.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.