This service bulletin provides the correction to the condition of the Malfunction Indicator Lamp being illuminated and/or the DTC P149E set.
full bulletin at NHTSA ↗2025 Buick Envision electrical problems
moderate Owners of the 2025 Buick Envision have filed 3 NHTSA complaints about the electrical at roughly $850 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See electrical across all vehicles →
Complaints
3
Recalls
0
Avg fix
$850
| Model year | electrical complaints |
|---|---|
| 2021 Envision | 5 |
| 2022 Envision | 5 |
| 2023 Envision | 3 |
| 2024 Envision | 3 |
| 2025 Envision (this page) | 3 |
When does it fail?
Of the 3 electrical complaints filed for the 2025 Buick Envision, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering electrical on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This technical bulletin provides repair information to correct a customer concern of Radio Software Update W23E-178.1.2-M174-SQBR6-93.3.
full bulletin at NHTSA ↗This warranty administration bulletin provides information for dealers/technicians on System Reset and Connector Reconnect Labor Code Numbers.
full bulletin at NHTSA ↗This bulletin provides a procedure on how to check for a battery drain utilizing the Picoscope and how to measure the load on the system that may be causing a drain.
full bulletin at NHTSA ↗This technical bulletin provides repair information to correct a customer concern of Radio Software Update W23E-178.1.2-M174-SQBR6-93.3
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
On [XXX], I started the car. Very loud, cracking noise came from radio. Turned off radio, noise stopped. When I used turn signal, noise came from turn lever. Turned off signal, noise stopped. Put car in park and pushed ignition button to turn off. Noise came thru ignition button. Later restarted the car, noise was gone. Concerned there is a power surge going thru system. Saw same problem for…
While driving the dash and radio randomly turn off. Sometimes staying black for minutes others until you stop the car and walk away for several minutes. Leaving you without a way to tell how fast you are going, or any other safety information, fuel level or more.
The contact owns a 2025 Buick Envision. The contact stated that upon picking up the vehicle from the dealer a day after purchasing the vehicle, while attempting to start the vehicle, the vehicle failed to start, with several unknown warning lights illuminated. The dealer replaced the battery; however, the failure persisted. The vehicle was taken back to the dealer, where it was determined that…
Had electrical trouble with your 2025 Buick Envision?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the electrical problem on the 2025 Buick Envision?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $850 and most owners catch it before it causes a breakdown.
At what mileage does the electrical typically fail?
Based on the 3 complaints filed, electrical issues most often appear around 2,700 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $850 for electrical repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to electrical?
No active recalls currently cover electrical issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2025/Buick/Envision.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.