This informational bulletin instructs the tech when fuel/fluid is needed to be tested and where it can be sent for analysis.
full bulletin at NHTSA ↗2025 Chevrolet Colorado brakes problems
severe Owners of the 2025 Chevrolet Colorado have filed 10 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
Complaints
10
Recalls
0
Avg fix
$450
| Model year | brakes complaints |
|---|---|
| 2021 Colorado | 10 |
| 2022 Colorado | 6 |
| 2023 Colorado | 18 |
| 2024 Colorado | 18 |
| 2025 Colorado (this page) | 10 |
1crash
When does it fail?
Of the 10 brakes complaints filed for the 2025 Chevrolet Colorado, here's the actual mileage breakdown — failures cluster heaviest at 100,000-125,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This informational bulletin provides information on the brake system warning lamp illuminated on driver information center (DIC), brake pedal goes closer to the floor and/or is harder to push.
full bulletin at NHTSA ↗This service bulletin provides customer information for rear unwanted automatic braking, usually when reversing out of a garage or driveway.
full bulletin at NHTSA ↗This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
full bulletin at NHTSA ↗This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 9 most recent
I was driving down a hill and hit my brakes and the pushed back against me and then went right to the floor with minimal braking. I got an error message on my dash that said “brake system failure- do not exceed 62 mph” Luckily it was early in the morning and nobody was in front of me. All of the lights were green and between the engine braking and the little brake power that I had I made it up…
On the day of purchase, while driving on a freeway, the vehicle would not accelerate. The RPM's went up, the engine revved, but the vehicle acted as if it was in neutral. These vehicles will not accelerate if they think the brake pedal is also being pressed. The brake was not being depressed. As I was pulling the vehicle to the side of the road, suddenly it allowed me to accelerate again, and I…
Many warning lights are on for traction control, abs , brakes service ESC, trailer braking and the adaptive cruise control system is not working, it was reported to the dealer, they checked it said bad battery, they coded it out said it is fine now on 9/5/25. It’s back at the dealer with all the same warnings on again
[XXX] I purchased a 2025 Chevrolet Colorado zr2 Midnight Edition from Preston Hood Chevrolet in Crestview, Florida. I had been waiting to see this truck for a couple days as it was listed on their website. They said it was in service but when I asked why they did not tell me. When I went to the dealership to buy it I asked again why it had been in service and the salesman said he did not know but…
This truck was purchased May 2025 and currently has 2600 miles. Without any warning the brake light and ABS warning lights came on along with messages reading Brake Assist,ESC, and Trailer Brake require service. I took my truck in to a Chevrolet dealer on Aug 18, 2025 for inspection of issue. I was informed the Master Cylinder has failed and because this was a “SAFETY” issue I could not take…
Started the vehicle and 4 dash lights were on. The ABS light, the forward collision system light, the BRAKE light, and the traction control light. The vehicle was taken to a dealership and we have been notified by the dealer that it is a Master Brake Cylinder failure. The part is on national backorder with no ETA. Luckily, it did not fail while driving, but could've been tragic. This vehicle…
The contact's husband owns a 2025 Chevrolet Colorado. The contact stated that after exiting a car wash tunnel and parking the vehicle on the side of the car wash building, the vehicle continued to roll forward at a high speed without warning. The contact used both feet and excessive force on the brake pedal to stop the vehicle; however, the vehicle continued to roll forward. The vehicle ran over…
At 6700 miles, the following warning lights came on: Service Trailer Brake Service ESC Service Brake Assist Adaptive Cruise control unavailable. I brought the truck to the dealer. They read the codes and found a service bulletin. “6721 found service bulletin for code C055F vehicle needs a master cylinder/booster/ebcm parts ordered” They told me it was safe to drive but I refused to drive given…
Brake pedal went to the floor when I applied the brakes, took truck to dealership. Dealership reported to me the master clylinder was defective and needed to order one from detroit.
Had brakes trouble with your 2025 Chevrolet Colorado?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2025 Chevrolet Colorado?
It's a meaningful issue. 10 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $450.
At what mileage does the brakes typically fail?
Based on the 10 complaints filed, brakes issues most often appear around 111,817 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2025/Chevrolet/Colorado.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.