Cause unknown, however, I have discovered that the engine in my Suburban, the Engine code LZO 3.0L Duramax, has damaged itself internally. I have been told that there is a large batch of engines that have this same problem, and the dealership I sent my car to has several cars in the same position. This problem is causing the engine to lock up or completely quit. This could be serious depending on…
2025 Chevrolet Suburban engine problems
moderate Owners of the 2025 Chevrolet Suburban have filed 11 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
11
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2021 Suburban | 66 |
| 2022 Suburban | 35 |
| 2023 Suburban | 55 |
| 2024 Suburban | 16 |
| 2025 Suburban (this page) | 11 |
When does it fail?
Of the 11 engine complaints filed for the 2025 Chevrolet Suburban, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Engine accounts for 41% of every owner complaint on file for this vehicle — the dominant problem area across 3 categories tracked.
What owners are reporting 7 most recent
The engine in 2025 Suburban (6.2L V8) has failed and the car is not drivable. It is currently in a Chevy dealership service department waiting for parts. The 2025 model is not listed under the recall. However it should be, I know of 3 2025 engines that have recently failed. I was passing a vehicle and as I took my foot off the accelerator the transmission shifted 2 times and then the engine shut…
3.0 Duramax engine failure at 5900 miles. Apparently is from the known thrust bearing issue. MIL, CEL, TCM illuminated. Failure occurred at 60 mph during rush hour traffic. Engine is being replaced under warranty. GM should issue recall for the affected lot of this engine.
3.0 Duramax, thrust bearing engine failure. Less than 6000 miles on vehicle. Driving at 60 mph when vehicle went into major limp mode. Had TCM, Charging and coolant lights illuminate. GM is replacing engine under warranty. Indicated there was approximately a 2 week engine production window where this issue is being traced back to. GM should issue recall if they know the extent of condition…
The contact owns a 2025 Chevrolet Suburban. The contact stated that while driving 25 MPH, a yellow triangle warning icon was displayed, and a message to "Please Add Oil" was displayed. The vehicle was taken to a dealer, where it was diagnosed with a broken part and oil was leaking oil onto the oil filter. The vehicle was repaired. The contact stated that approximately 1,000 miles later, the same…
Driving on Highway at approx 70mph, lost propulsion and speedometer went to 0. Came back after approx. 5 seconds. After exiting highway and stopping, clear knocking/clanging noise from engine. GM states full engine replacement needed. This is a 2025 6.2 V8, thought these issues were fixed?
We have 8,625 miles on our 2025 Suburban. We were going down the highway when began to hear a unfamiliar noise. We pulled over into an error to inspect and didn't notice anything under the vehicle, which we thought might have cause the noise. We put into drive and went less than an 1/8 of a mile and our suburban lost acceleration and stopped. It would not start and couldn't not be moved,…
Had engine trouble with your 2025 Chevrolet Suburban?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2025 Chevrolet Suburban?
It's a documented issue but not catastrophic. 11 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 11 complaints filed, engine issues most often appear around 2,203 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2025/Chevrolet/Suburban.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.