FORD: PREMATURE FRONT/REAR TIRE WEAR AND/OR VEHICLE DRIFT ON WET OR SNOW COVERED ROADS. IF PERFORMING AN ALIGNMENT, RECORD ALL ALIGN-MENT ANGLES PRIOR TO ANY ADJUSTMENTS, AND ENTER IN WARRANTY CLAIM IF APPLICABLE.
full bulletin at NHTSA ↗2005 Ford Focus tires problems
severe Owners of the 2005 Ford Focus have filed 8 NHTSA complaints about the tires at roughly $150 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See tires across all vehicles →
Complaints
8
Recalls
0
Avg fix
$150
| Model year | tires complaints |
|---|---|
| 2005 Focus (this page) | 8 |
| 2006 Focus | 10 |
| 2007 Focus | 18 |
| 2008 Focus | 15 |
| 2009 Focus | 11 |
1crash
1injury
When does it fail?
Of the 8 tires complaints filed for the 2005 Ford Focus, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA tires complaint has been filed on this vehicle in over 19 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering tires on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 1 most recent
I was westbound on 5th st. In olivehurst, ca, and headed to olivehurst drive. The conditions were dry and cool, and the speed limit was 25 MPH. I had not yet come up to the speed limit (below 10 MPH) when my front end began to shake. Seconds later, my passenger and I heard a loud bang, and the front end swerved sharply to the right. I tried to correct to the left, and ended up clipping a pole…
Had tires trouble with your 2005 Ford Focus?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the tires problem on the 2005 Ford Focus?
It's a meaningful issue. 8 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $150.
At what mileage does the tires typically fail?
Based on the 8 complaints filed, tires issues most often appear around 45,390 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $150 for tires repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to tires?
No active recalls currently cover tires issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2005/Ford/Focus.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.