Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2006 Saab 9-3 fuel system problems
moderate
Owners of the 2006 Saab 9-3 have filed 4 NHTSA complaints about the fuel system at roughly $1,200 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation.See fuel system across all vehicles →
Ti automotive is recalling certain fuel pumps, part numbers tu456 and tu303, sold under various brand names as aftermarket and replacement equipment for the motor vehicles listed above
A vehicle crash could occur should the engine stall while in use.
Fix: Ti automotive will notify owners of record and will replace any defective fuel pump with a new or reworked fuel pump free of charge. The safety recall began on february 22, 2011. Owners may contact ti automotive at 1-866-867-3759 or log on to www.recallresponse.com.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering fuel system on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service Bulletin07-053Jun 2008
SAAB SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-FUEL TANK FILLER CAP. VEHICLE MAY EXPERIENCE A CONDITION WHERE THE FUEL TANK CAP WON'T TIGHTEN PROPERLY OR THE FUEL TANK CAP WON'T COME OFF OR IS BROKEN. CSC LETTER WAS RECEIVED. UPDATED 12/1/08.
SAAB SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-FUEL TANK FILLER CAP. A CONDITION WHERE THE FUEL TANK CAP WON'T TIGHTEN PROPERLY, OR THE FUEL TANK CAP WON'T COME OFF, OR IS BROKEN. CSC LETTER WAS RECEIVED.
GENERAL MOTORS: SOME VEHICLES MAY EXPERIENCE A CONDITION WHERE THE FUEL TANK CAP WON'T TIGHTEN PROPERLY, OR FUEL TANK CAP WON'T COME OFF, OR IS BROKEN. THESE CONDITIONS MAY ALSO CAUSE THE ILLUMINATION OF THE MALFUNCTION INDICATOR LIGHT (MIL).
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
0 most recent
Had fuel system trouble with your 2006 Saab 9-3?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the fuel system problem on the 2006 Saab 9-3?
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $1,200 and most owners catch it before it causes a breakdown.
At what mileage does the fuel system typically fail?
Based on the 4 complaints filed, fuel system issues most often appear around 123,878 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,200 for fuel system repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to fuel system?
Yes — 1 active recall(s) cover fuel system issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Saab/9-3.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.