Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the faulty roller follower(s). When replacing the camshaft roller followers, refer to Workshop Manual (WSM), Section 303-01.
full bulletin at NHTSA ↗2007 Lincoln Navigator engine problems
severe 3 complaints filed with NHTSA · avg repair $3,100 · see engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
1fire
When does it fail?
Of the 3 engine complaints filed for the 2007 Lincoln Navigator, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Of the 9 model years of Lincoln Navigator we track for engine problems, this one has the fewest owner complaints on file (3).
No new NHTSA engine complaint has been filed on this vehicle in over 10 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
full bulletin at NHTSA ↗LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR.
full bulletin at NHTSA ↗BUCK/JERK/HESITATION - LESS THAN 1/4 TANK OF FUEL.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
Tl* the contact owns a 2007 Lincoln navigator. While driving approximately 60 MPH, the vehicle lost all power and stalled. The vehicle was towed to a dealer for diagnostic testing. The technician stated that the fuel tank failed. The manufacturer was not notified of the failure. The approximate failure mileage was 120,000.
The contact owns a 2007 Lincoln Navigator. The contact stated while driving 35 MPH, there was an abnormal sound coming from the engine compartment, prompting the contact to pull over to the shoulder of the roadway. The vehicle was towed to the residence. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the rocker arms, finding that the engine…
Tl*the contact owns a 2007 Lincoln navigator. While the vehicle was parked, the contact heard a popping noise followed by a loud explosion. He noticed that the vehicle was on fire. He then heard more popping sounds and noticed that the vehicle was completely engulfed in flames. The fire destroyed the vehicle and melted the sidings of the house and shed. The vehicle has not been inspected to…
Had engine trouble with your 2007 Lincoln Navigator?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2007 Lincoln Navigator?
It's a meaningful issue. 3 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $3,100.
At what mileage does the engine typically fail?
Based on the 3 complaints filed, engine issues most often appear around 65,500 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2007/Lincoln/Navigator.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.