This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
full bulletin at NHTSA ↗2007 Saturn Relay body problems
moderate 3 complaints filed with NHTSA · avg repair $1,500 · see body across all vehicles →
Complaints
3
Recalls
0
Avg fix
$1,500
When does it fail?
Of the 3 body complaints filed for the 2007 Saturn Relay, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA body complaint has been filed on this vehicle in over 17 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering body on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
full bulletin at NHTSA ↗This warranty bulletin provides labor operation numbers for customer concerns that cant be duplicated.
full bulletin at NHTSA ↗THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS.
full bulletin at NHTSA ↗This informational bulletin provides information on removing paint stains on the under side of protective shipping film
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
I own a 2007 Saturn relay 3 minivan. The van has dual power assisted rear sliding cargo doors. During my family's evacuation for hurricane gustav the passenger side power assisted sliding cargo door did not close properly (did not latch). I electrically re-closed the door and locked the vehicle. During the week of september 1st through september 7th the same door would not close properly,…
I went to get my 2 year old out of the van and the whole door fell off just missing my feet. *tr updated 09/09/08. *jb
I own a 2007 Saturn relay. I have had nothing but problem with the rear sliding doors. I bought in april of 2007. It was used. The passenger door started opening when I was driving. One night when I stopped to get gas a passenger got out and the door fell off. Took to dealership. Was covered under warranty they also had to paint passenger side. A few months later, the drivers side started opening…
Had body trouble with your 2007 Saturn Relay?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the body problem on the 2007 Saturn Relay?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $1,500 and most owners catch it before it causes a breakdown.
At what mileage does the body typically fail?
Based on the 3 complaints filed, body issues most often appear around 20,407 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,500 for body repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to body?
No active recalls currently cover body issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2007/Saturn/Relay.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.