This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
full bulletin at NHTSA ↗2008 Chevrolet Colorado lighting problems
moderate Owners of the 2008 Chevrolet Colorado have filed 4 NHTSA complaints about the lighting at roughly $250 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See lighting across all vehicles →
Complaints
4
Recalls
0
Avg fix
$250
| Model year | lighting complaints |
|---|---|
| 2005 Colorado | 40 |
| 2006 Colorado | 20 |
| 2007 Colorado | 15 |
| 2008 Colorado (this page) | 4 |
| 2011 Colorado | 3 |
When does it fail?
Of the 4 lighting complaints filed for the 2008 Chevrolet Colorado, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA lighting complaint has been filed on this vehicle in over 15 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering lighting on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
full bulletin at NHTSA ↗This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
full bulletin at NHTSA ↗This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.
full bulletin at NHTSA ↗This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
The right headlight on the vehicle continually has condensation in it. It has been replaced by dealer twice in 18 or so months. Now it has condensation in it again. It is a Chevrolet colorado 2008. The truck has not been wrecked or damaged. I'm taking it back to the dealer again in few weeks before the warranty runs out. This problem first appeared with less than 8,000 miles on the truck.…
Tl* the contact owns a 2008 Chevrolet colorado. While driving approximately 70 MPH, the cruise control failed to function. While inspecting the cruise control when the vehicle was parked, the contact noticed that the brake lights failed to function. There were no warning indicators illuminated on the instrument panel. The vehicle was not taken to a dealer or an independent mechanic to determine…
Tl* the contact owns a 2008 Chevrolet colorado. The contact stated that the vehicle was repaired under NHTSA campaign number: 09v310000 (exterior lighting). While stopped at a stop light, another driver informed the contact that the brake lights were not illuminated. The contact called the manufacturer and was informed that the vehicle had already been repaired under the recall and could not be…
Had lighting trouble with your 2008 Chevrolet Colorado?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the lighting problem on the 2008 Chevrolet Colorado?
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $250 and most owners catch it before it causes a breakdown.
At what mileage does the lighting typically fail?
Based on the 4 complaints filed, lighting issues most often appear around 75,125 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $250 for lighting repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to lighting?
No active recalls currently cover lighting issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2008/Chevrolet/Colorado.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.