This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
full bulletin at NHTSA ↗2008 Chevrolet Uplander body problems
moderate Owners of the 2008 Chevrolet Uplander have filed 9 NHTSA complaints about the body, typically surfacing around 53,880 miles at roughly $1,500 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See body across all vehicles →
Failure mileage
Complaints
9
Recalls
0
Avg fix
$1,500
| Model year | body complaints |
|---|---|
| 2005 Uplander | 34 |
| 2006 Uplander | 20 |
| 2007 Uplander | 23 |
| 2008 Uplander (this page) | 9 |
When does it fail?
Of the 9 body complaints filed for the 2008 Chevrolet Uplander, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Of the 4 model years of Chevrolet Uplander we track for body problems, this one has the fewest owner complaints on file (9).
No new NHTSA body complaint has been filed on this vehicle in over 14 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering body on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
full bulletin at NHTSA ↗This warranty bulletin provides labor operation numbers for customer concerns that cant be duplicated.
full bulletin at NHTSA ↗This Informational bulletin describes warranty part reviews where door glass had chips or scratches.
full bulletin at NHTSA ↗THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
Tl* the contact owns a 2008 Chevrolet uplander. The contact stated that the rear driver side sliding door would haphazardly open while the vehicle was in motion and could not be closed securely. The vehicle was taken to the dealer approximately eight times for the failure where the dealer replaced several unknown parts and readjusted the alignment, but to no avail. The manufacturer was notified…
Our 2008 Chevrolet uplander van is utilized to deliver campus mail. This past week the carrier hand was caught in the door while unloading/loading mail. Luckily there was no major damage done to her hand but that may not be the case the next time. There are no locking position on the two sliding side doors. We have to park on inclines. This accident may happen again. I have an older van and…
Tl* the contact owns a 2008 Chevrolet uplander. The contact stated that the rear driver side sliding door opened while the contact was driving 40 MPH. The contact stated hat the failure would occur when any road bump was driven over. The contact took the vehicle to the dealer and the dealer could not identify the problem. The dealer advised that once the problem recurred, to bring the vehicle…
The child safety lock on the passenger power sliding door. The switch will slide into place but will not prevent door from opening from inside. *tr
Had body trouble with your 2008 Chevrolet Uplander?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the body problem on the 2008 Chevrolet Uplander?
It's a documented issue but not catastrophic. 9 complaints have been filed. Repairs average $1,500 and most owners catch it before it causes a breakdown.
At what mileage does the body typically fail?
Across the 8 complaints that reported odometer mileage, most body failures cluster between 30,000 and 60,324 miles, with the median around 53,880. A quarter of owners report trouble before 30,000; a quarter make it past 60,324. Maintenance history matters more than the odometer alone — this is the reported failure window, not a guarantee.
What does it cost to fix?
Independent shops typically charge around $1,500 for body repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to body?
No active recalls currently cover body issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2008/Chevrolet/Uplander.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.