Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2009 Chevrolet Aveo brakes problems
severe
Owners of the 2009 Chevrolet Aveo have filed 3 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation.See brakes across all vehicles →
Complaints
3
Recalls
1
Avg fix
$450
brakes complaints on the Chevrolet Aveo, by model year
Of the 3 brakes complaints filed for the 2009 Chevrolet Aveo,
here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
0 (0%)
25-50k
1 (100%)
50-75k
0 (0%)
75-100k
0 (0%)
100-125k
0 (0%)
125-150k
0 (0%)
150k+
0 (0%)
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted.
Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits
and driving conditions shift the curve as much as mileage alone.
What stands out
Of the 7 model years of Chevrolet Aveo we track for brakes problems, this one has the fewest owner complaints on file (3).
No new NHTSA brakes complaint has been filed on this vehicle in over 10 years — the issue may be aging out of the active population.
General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Aveo and 2009 Pontiac G3 vehicles
If the ABS valve corrodes it may result in longer brake pedal travel or reduced performance, increasing the risk of a vehicle crash.
Fix: GM will notify owners, and dealers will replace the ABS module, free of charge, in any vehicle that did not have its module replaced under a previous customer satisfaction campaign. The recall began in late September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), and 1-800-762-2737 (Pontiac). GM's number for this recall is 14505.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service Bulletin15-00-89-004ESep 2022
This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
This informational bulletin provides information on installing the correct tires for vehicles with the condition of under hard acceleration at higher speeds, the traction control light will flash. Or, they may come in for ABS or general handling/braking concerns.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
1 most recent
brakes · 40,000 mi
· filed 11/18/2015
Tl* the contact owned a 2009 Chevrolet aveo. While driving at approximately 40 MPH, the brake pedal was depressed and failed to respond without warning, which caused the vehicle to crash into another vehicle. In addition, the contact's vehicle continued to accelerate and caused another vehicle to crash into the front driver side. The contact sustained head and shoulder injuries that required…
Had brakes trouble with your 2009 Chevrolet Aveo?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2009 Chevrolet Aveo?
It's a meaningful issue. 3 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $450.
At what mileage does the brakes typically fail?
Based on the 3 complaints filed, brakes issues most often appear around 38,950 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
Yes — 1 active recall(s) cover brakes issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2009/Chevrolet/Aveo.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.