COMM-TRANS LUND: SOME 2009-2011 MODELS MAY HAVE THE AIR BAG INICATOR FLASHING WITH A STORED TROUBLE CODE. THIS IS A SOFTWARE PROBLEM.
full bulletin at NHTSA ↗2010 Ford Flex airbags problems
severe 7 complaints filed with NHTSA · avg repair $1,100 · see airbags across all vehicles →
Complaints
7
Recalls
0
Avg fix
$1,100
5crashes
2injuries
When does it fail?
Of the 7 airbags complaints filed for the 2010 Ford Flex, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA airbags complaint has been filed on this vehicle in over 11 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering airbags on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 2 most recent
Tl* the contact owns a 2010 Ford flex. While driving 25 MPH the contact crashed head on into another vehicle after the other vehicle failed to stop at a stop sign. The air bag warning light remained illuminated prior to the crash. The air bags failed to deploy. The police advised the contact that due to the impact the air bags should have deployed. The fire department had to force the door open…
Tl* the contact owns a 2010 Ford flex. While waiting at a traffic light, a vehicle traveling approximately 40 MPH crashed into the rear of the contact's vehicle. As a result, the contact's vehicle crashed into the rear of a third vehicle. The vehicle was destroyed and the air bags failed to deploy. The contact suffered contusions to the abdomen and a left shoulder injury, which required medical…
Had airbags trouble with your 2010 Ford Flex?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the airbags problem on the 2010 Ford Flex?
It's a meaningful issue. 7 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $1,100.
At what mileage does the airbags typically fail?
Based on the 7 complaints filed, airbags issues most often appear around 69,803 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,100 for airbags repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to airbags?
No active recalls currently cover airbags issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2010/Ford/Flex.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.