Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how
full bulletin at NHTSA ↗2011 Ford Flex body problems
severe 3 complaints filed with NHTSA · avg repair $1,500 · see body across all vehicles →
Complaints
3
Recalls
0
Avg fix
$1,500
1injury
What stands out
Of the 7 model years of Ford Flex we track for body problems, this one has the fewest owner complaints on file (3).
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering body on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using
full bulletin at NHTSA ↗FORD: AN INTRUSION OF WATER, FROM MOVEABLE MOONROOF, DUE TO AN OVERFLOW OF TROUGH RAILS WHEN DRAIN SYSTEM HAS OVER CAPACITIZED. MODEL 2011-14 FLEX.
full bulletin at NHTSA ↗FORD/LINCOLN: WHEN ALL DOORS ARE CLOSED, THE DOOR AJAR LAMP WILL ILLUMINATE. MODEL 2011-2013 EDGE, EXPLORER, FLEX, MKX, MKT.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 0 most recent
Had body trouble with your 2011 Ford Flex?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the body problem on the 2011 Ford Flex?
It's a meaningful issue. 3 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $1,500.
At what mileage does the body typically fail?
Based on the 3 complaints filed, body issues most often appear around 44,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,500 for body repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to body?
No active recalls currently cover body issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2011/Ford/Flex.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.