Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
moderate Owners of the 2012 BMW 528i have filed 4 NHTSA complaints about the fuel system at roughly $1,200 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See fuel system across all vehicles →
| Model year | fuel system complaints |
|---|---|
| 2011 528i | 8 |
| 2012 528i (this page) | 4 |
Of the 4 fuel system complaints filed for the 2012 BMW 528i, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
No new NHTSA fuel system complaint has been filed on this vehicle in over 9 years — the issue may be aging out of the active population.
The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
The manufacturer has issued service bulletins covering fuel system on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
full bulletin at NHTSA ↗For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Fuel Injectors to 10 years/120,000 miles as determined by the vehicle's original in-service date.
full bulletin at NHTSA ↗INCORRECT TORQUE SPECIFICATION FOR THE HIGH-PRESSURE PUMP IN ISTA: The current version of ISTA states the incorrect tightening torque for the High-Pressure pump M6 mounting bolts to the cylinder head cover. The correct tightening torque is only 12 Nm for the M6 bolts.
full bulletin at NHTSA ↗NEW REPLACEMENT FUEL TANK INTERNAL FUEL LINE CONNECTION. INFORMATION WARRANTY INFORMATION Not applicable. This Service Information bulletin provides technical and repair procedure-related information.
full bulletin at NHTSA ↗N20 ENGINE OIL FEED LINE TO THE TURBOCHARGER:Within the BMW ÒmodelÓ vehicles listed above, BMW of North America, LLC (ÒBMW NAÓ) is extending the limited warranty for the engine oil feed line to the turbocharger
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
On two occasions vehicle suddenly offers an alert and stops accelerating and stalls on the freeway leaving us stranded. The car was taken to the BMW dealer and corporate was made aware of the situation after the first incident and didn't fix it. They kept it for about approx10 days and only replaced the battery. Three weeks later the second incident happened. This time we took a picture of the…
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $1,200 and most owners catch it before it causes a breakdown.
Based on the 4 complaints filed, fuel system issues most often appear around 62,429 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
Independent shops typically charge around $1,200 for fuel system repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Yes — 1 active recall(s) cover fuel system issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.