Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2012 Toyota Tundra airbags problems
severe
Owners of the 2012 Toyota Tundra have filed 6 NHTSA complaints about the airbags at roughly $1,100 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation.See airbags across all vehicles →
Complaints
6
Recalls
1
Avg fix
$1,100
airbags complaints on the Toyota Tundra, by model year
Of the 6 airbags complaints filed for the 2012 Toyota Tundra,
here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
1 (100%)
25-50k
0 (0%)
50-75k
0 (0%)
75-100k
0 (0%)
100-125k
0 (0%)
125-150k
0 (0%)
150k+
0 (0%)
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted.
Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits
and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA airbags complaint has been filed on this vehicle in over 8 years — the issue may be aging out of the active population.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Fix: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering airbags on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service BulletinTSB003220Aug 2023
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate.
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation. This service bulletin provides a guide on how to prepare the interior of the vehicle prior to an odor remediation being performed, as well as contact information for an approved vendor who will arrange the remediation, and instructions on how to prepare the interior of the vehicle for reassembly once the remediation has been completed. Refer to all model and
TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deployment of airbag and pre-tensioner assemblies as hazardous material treatment. Hazardous material treatment may require special training, certification or licensing in certain areas. TMS recommends that dealership personnel carefully review and follow ALL local and state regulations, and where necessary, contract with Environmental Protection Agency (EPA) Licensed Hazardous Waste Transportation and Disposal facilities.
Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
2 most recent
airbags
· filed 11/16/2017
Takata recall
airbags · 14,500 mi
· filed 11/13/2012
While using to horn the cover of the airbag split along the seam where the airbag deploys. The vehicle was brought into get scheduled service and Toyota's position is that it is not a warranty issue or safety issue. I placed 3 calls to Toyota customer experience center starting 10/26/2012 (case#[xxx]) with the problem and have not received a response! I am concerned that it may affect the way and…
Had airbags trouble with your 2012 Toyota Tundra?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the airbags problem on the 2012 Toyota Tundra?
It's a meaningful issue. 6 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $1,100.
At what mileage does the airbags typically fail?
Based on the 6 complaints filed, airbags issues most often appear around 19,029 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,100 for airbags repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to airbags?
Yes — 1 active recall(s) cover airbags issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2012/Toyota/Tundra.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.